1996 Ford Crown Victoria

Complaint history

When NHTSA received these reports. Changes in reporting alone do not establish a change in failure rates.

Problems owners report

Listed groups have at least 3 complaints. The page includes the 20 largest groups plus any additional flagged groups; some complaints are not assigned to a group.

AI groups complaints by meaning; the groups are approximate. Share ratio compares the problem’s share of this vehicle’s complaints with its share on other vehicles over the last 24 months (shown from 3 recent complaints). A 2× ratio means twice the complaint share, not twice the failure risk. Flags mark unusual shares or recent surges after an AI review of the complaint content. “First signal” does not mean the pattern has persisted continuously.How recall estimates are calculated.

Recalls

• NHTSA recall #08V051000February 4, 2008225,000 vehicles affected

  vehicle speed control: cruise control

  Ford is recalling 225,000 my 1992-2003 econoline, my 1993-1995 taurus sho, my 1992-1998 Crown Victoria, my 1993 bronco, f-series, my 1995-1997 f-series super duty stripped chassis, my 1992-1998 mercury grand marquis, and my 1992-1995 Lincoln town car vehicles. The affected vehicles were previously repaired using a wiring harness that is not compatible with the vehicle circuit polarity.

  As a result, the fuse is located in the output circuit rather than in the intended input power feed circuit, and may not offer the intended protection in the event of an electrical short to ground.

  Remedy

  Dealers will install a new wiring harness, or replace the mating electrical component. The recall began on february 18, 2008. Owners may contact Ford at 1-800-392-3673.

• NHTSA recall #07V336000August 3, 20073,600,000 vehicles affected

  vehicle speed control

  On certain pickup trucks, passenger vehicles, sport utility vehicles, and motor homes chassis, the speed control deactivation switch may, under certain conditions, leak internally and then overheat, smoke, or burn.

  This could result in an underhood fire.

  Remedy

  Dealers will install a fused wiring harness. Owners of the passenger cars included in this campaign will be instructed to return their vehicles to their dealers to have the speed control deactivation switch disconnected as an interim repair. As soon as repair parts are available (expected october 2007), owners will be instructed to return to the dealers for installation of a fused wiring harness. The recall began on august 13, 2007, and mailing completed by september 19, 2007. Owners may contact Ford at 1-888-222-2751.

• NHTSA recall #03V472000November 6, 20034,218 vehicles affected

  fuel system, other: storage: tank assembly

  On certain natural gas vehicles, if a flame from a vehicle interior fire becomes locally directed at the natural gas fuel tank located immediately behind the rear seat, the flame could damage the fiberglass wrap on the tank weakening the tank.

  If the strength of the tank is significantly compromised, it could rupture, increasing the risk of a fire.

  Remedy

  Dealers will install an insulator behind the current seat back. Owner notification began on january 7, 2004. Owners should contact Ford at 1-800-392-3673.

• NHTSA recall #00V157001June 12, 20001,167 vehicles affected

  seat belts: front: anchorage

  Vehicle description: passenger vehicles using aftermarket driver's seat belt assemblies that were sold by Ford parts departments from january 1, through june 13, 2000. These seat belt assemblies fail to comply with the requirements of FMVSS no. 209, "seat belt assemblies." the equipment involved is service stock seat belt assemblies, model nos. H 9977, h 9979, t 9063, and t 9217, built by trw vehicle safety systems, inc. (trw) manufactured from june 1, 1998 through may 21, 2000. Some of these seat belt assemblies may have been installed as service replacement equipment on the vehicles involved in the recall.

  In the event of a collision, these seat belts may not restrain an occupant increasing the risk of injury.

  Remedy

  Dealers will inspect these vehicles and replace the service seat belt assemblies that were installed in these vehicles from january 1 through june 13, 2000.

• NHTSA recall #00V157002June 12, 20001,129 vehicles affected

  seat belts: front: anchorage

  Vehicle description: passenger vehicles using aftermarket front passenger side seat belt assemblies that were sold by Ford parts departments from january 1, through june 13, 2000. These seat belt assemblies fail to comply with the requirements of FMVSS no. 209, "seat belt assemblies." the equipment involved is service stock seat belt assemblies, model nos. H 9977, h 9979, t 9063, and t 9217, built by trw vehicle safety systems, inc. (trw) manufactured from june 1, 1998 through may 21, 2000. Some of these seat belt assemblies may have been installed as service replacement equipment on the vehicles involved in the recall.

  In the event of a collision, these seat belts may not restrain an occupant increasing the risk of injury.

  Remedy

  Dealers will inspect these vehicles and replace the service seat belt assemblies that were installed in these vehicles from january 1 through june 13, 2000.

• NHTSA recall #98V322000December 16, 1998175,000 vehicles affected

  suspension: front: control arm: lower ball joint

  Vehicle description: certain 1996-1999 Ford Crown Victoria police, fleet, natural gas, and 1996-1999 Lincoln town car limousine vehicles that were produced with a lower control arm ball joint containing a one piece bearing; and 1990-1996 Ford Crown Victoria police, fleet, and ngv vehicles and 1990-1996 Lincoln town car limousine vehicles that have been serviced with either a ball joint containing the one-piece bearing or a front lower control arm containing a ball joint with a one-piece bearing. The one-piece bearing within the lower control arm ball joint Can weaken slowly during use and eventually crack. This could result in separation of the ball and cap of the joint, allowing the control arm to drop to the ground.

  If this occurs while the vehicle is moving, reduced steering control could occur, increasing the risk of a crash.

  Remedy

  Dealers will replace the lower control arm ball joints (2).

• NHTSA recall #97V024000March 4, 1997125,000 vehicles affected

  latches/locks/linkages: hood: latch

  Vehicle description: police and taxi vehicles. The hood latch striker Can wear or become detached from the hood.

  Either of these conditions Can result in the hood opening without warning while the vehicle is being operated impairing the driver's visibility.

  Remedy

  Dealers will install an improved hood latch striker (vehicles with 1992 model hoods) or revised striker plate attaching fasteners (vehicles with 1993-1997 model hoods).

• NHTSA recall #96V135000July 18, 199672,000 vehicles affected

  steering: linkages

  The pitman arms were not fully lubricated at the assembly plant. The "ball joint" at the outer end of the pitman arm Can become contaminated and corrode.

  Such corrosion Can result in abnormal wear of the joint, resulting in separation of the joint. Loss of steering control Can occur increasing the risk of a vehicle accident.

  Remedy

  Dealers will inspect the vehicles and if the joint is found to have significant wear, the arm will be replaced. Those pitman arms not replaced will have the "ball joint" fully greased.

• NHTSA recall #96V070000April 22, 199673,500 vehicles affected

  latches/locks/linkages: doors: latch

  When in the secondary latched position, the driver door latches may open when subjected to transverse loads less than that specified in FMVSS no. 206, "door locks and door retention components."

  The driver's door, when closed only to the secondary latched position, may not sustain a 1,000 pound transverse load.

  Remedy

  Dealers will inspect and, if necessary, replace the driver door latch.

Other model years

• 1986 27
• 1987 41
• 1988 42
• 1989 72
• 1990 43
• 1991 55
• 1992 310
• 1993 182
• 1994 192
• 1995 250
• 1996
• 1997 288
• 1998 119
• 1999 134
• 2000 85
• 2001 53
• 2002 58
• 2003 249
• 2004 138
• 2005 193
• 2006 53
• 2007 50
• 2008 50
• 2009 44