2003 Chevrolet Venture

Complaint history

When NHTSA received these reports. Changes in reporting alone do not establish a change in failure rates.

Problems owners report

Listed groups have at least 3 complaints. The page includes the 20 largest groups plus any additional flagged groups; some complaints are not assigned to a group.

AI groups complaints by meaning; the groups are approximate. Share ratio compares the problem’s share of this vehicle’s complaints with its share on other vehicles over the last 24 months (shown from 3 recent complaints). A 2× ratio means twice the complaint share, not twice the failure risk. Flags mark unusual shares or recent surges after an AI review of the complaint content. “First signal” does not mean the pattern has persisted continuously.How recall estimates are calculated.

Recalls

• NHTSA recall #07V349000August 8, 200720,594 vehicles affected

  fuel system, gasoline: storage

  On certain vehicles, variations in the manufacturing process or exposure to high ambient temperatures may lead to fracture of the fuel tank inlet check valve (icv).

  A fracture may allow fuel vapors to pass through and allow droplets of fuel to accumulate on the side of the fuel tank. Fuel leakage, in the presence of an ignition source, could result in a fire.

  Remedy

  Dealers will replace the fuel tank. The recall will be mailed in two phases with the first phase beginning on december 4, 2007. The second phase will be mailed on december 13, 2007. Owners may contact Buick at 1-866-608-8080; Chevrolet at 1-800-630-2438; or Pontiac at 1-800-620-7668. The vehicle population includes Buick rendezvous and Pontiac aztek vehicle built in may 2003; Chevrolet Venture and Pontiac montana vehicles built from june through august 2002; and all vehicles registered in nevada, arizona, virgin islands, puerto rico, and hawaii.

• NHTSA recall #04V597000December 22, 2004717,302 vehicles affected

  latches/locks/linkages: doors: latch

  On certain minivans equipped with second-row bucket seats or captain's chairs and a power sliding door on the passenger side of the vehicle, a passenger using the interior handle to open the power sliding door could be injured.

  If a passenger uses the interior handle to open the power sliding door and holds onto the handle while it is being opened by the motor, the passenger's arm may be pushed into the seat back or armrest and a wrist or lower arm injury may result.

  Remedy

  Dealers will replace the power sliding door interior handle on the passenger-side. If the vehicle is equipped with a power or manual sliding door on the driver-side, the interior handle will also be replaced for appearance reasons. Note: before the vehicle is serviced, gm advises owners to not use the interior door handle to open the door. The driver Can open and close the door from switches at the driver's position or by using the remote key fob. The driver should tell passengers to use the switch located in front of the door to open or close it. The driver should use the override switch to prevent operation of the power door by children or by others who are not familiar with its use. The owner notification letter mailing will be conducted in phases with the first phase beginning on may 31, 2005. The second phase mailing began on july 18, 2005. The recall began on may 31, 2005. Phase 2 began on july 18, 2005. Phase 3 (final phase) began on august 24, 2005, to all remaining customers. Owners should contact Chevrolet at 1-800-630-2438; Pontiac at 1-800-620-7668; or Oldsmobile at 1-800-630-6537.

• NHTSA recall #03V250000July 15, 20031,707,825 vehicles affected

  equipment: other: owners/service/other manual

  Certain minivans, passenger and sport utility vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 225, "child restraint anchorage system." the owner's manual does not explain the meaning of the location symbols for the child restraint lower universal anchorage system.

  This does not meet the requirements of the standard.

  Remedy

  Owners will be provided with a supplement for their owner's manual. This supplement describes and shows the location symbols for the child restraint anchors that are located in the vehicle and on the child restraint or booster cushion. Owner notification began august 18, 2003. Owners should contact Buick at 1-866-608-8080, Cadillac at 1-866-982-2339, Chevrolet at 1-800-630-2438, Gmc at 1-866-996-9463, Pontiac at 1-800-620-7668, or Oldsmobile at 1-800-630-6537.

• NHTSA recall #03V051000February 14, 2003130 vehicles affected

  air bags: frontal: driver side: inflator module

  On certain mini vans, passenger and sport utility vehicles, some of these vehicles have a driver's side air bag that may not deploy as designed. In addition, the air bag inflator could rupture.

  This could result in reduced capability of the air bag to protect the driver. Also if the air bag inflator ruptured, pieces of the inflator could strike and injure the vehicle occupants.

  Remedy

  Dealers will inspect, and if necessary, install a new driver's air bag. Owner notification began on march 11, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact Buick at 1-800-521-7300, Cadillac at 1-800-458-8006, Chevrolet at 1-800-222-1020, Gmc at 1-800-462-8782, or Pontiac at 1-800-762-2737.

• NHTSA recall #02V222000August 9, 2002133,221 vehicles affected

  air bags: frontal

  Certain passenger, mini vans, and sport utility vehicles have an air bag inflator on the driver's side that could fracture at a weld during a deployment.

  Pieces of the inflator could strike and injure vehicle occupants and the air bag cushion would not inflate fully, reducing the capability of the bag to protect the driver.

  Remedy

  Dealers will inspect, and replace, if necessary, the air bag module assembly on the driver's side. Owner notification began august 15, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact Buick at 1-800-521-7300, Cadillac at 1-800-458-8006, Chevrolet at 1-800-222-1020, Gmc at 1-800-462-8782, Oldsmobile at 1-800-442-6537, or Pontiac at 1-800-762-2737.

Other model years

• 1997 432
• 1998 409
• 1999 349
• 2000 350
• 2001 222
• 2002 220
• 2003
• 2004 124
• 2005 42