2006 Chevrolet Corvette

Complaint history

When NHTSA received these reports. Changes in reporting alone do not establish a change in failure rates.

Problems owners report

Listed groups have at least 3 complaints. The page includes the 20 largest groups plus any additional flagged groups; some complaints are not assigned to a group.

AI groups complaints by meaning; the groups are approximate. Share ratio compares the problem’s share of this vehicle’s complaints with its share on other vehicles over the last 24 months (shown from 3 recent complaints). A 2× ratio means twice the complaint share, not twice the failure risk. Flags mark unusual shares or recent surges after an AI review of the complaint content. “First signal” does not mean the pattern has persisted continuously.How recall estimates are calculated.

Recalls

• NHTSA recall #14V251000May 14, 2014103,158 vehicles affected

  electrical system: wiring; exterior lighting: headlights

  General Motors LLC (GM) is recalling certain model year 2005-2007 Chevrolet Corvette vehicles manufactured March 29, 2004, through June 22, 2007. In the affected vehicles, the underhood bussed electrical center (UBEC) housing can expand and cause the headlamp low beam relay control circuit wire to bend. If the wire is repeatedly bent, it may fracture causing a loss of low beam headlamp illumination.

  The loss of low beam headlamp illumination will decrease the driver's visibility, as well as the vehicle's conspicuity to other motorists, increasing the risk of a crash.

  Remedy

  GM will notify owners, and dealers will install a jumper wire to correct this condition, free of charge. The recall began January 2, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 13146. Note: Model year 2008-2013 Chevrolet Corvettes will be covered under customer satisfaction program number 14203 for the same issue.

• NHTSA recall #10V172000April 26, 201040,028 vehicles affected

  steering: column

  Gm is recalling certain model year 2005 and 2006 Chevrolet Corvette passenger cars manufactured between march 2004 and january 2006 equipped with a tilt and telescoping steering column (rpo N37). In rare cases, repeated movement of the steering column may cause a signal interruption within the column. If this occurs, the message, "service active handling system" will appear in the driver information center, and one or more of the brakes may apply, possibly causing the vehicle to pull to the right or left.

  If the driver does not respond to the change in vehicle movement, a crash could occur.

  Remedy

  Gm will notify owners and dealers will repair the vehicles free of charge. The safety recall began on april 30, 2010. Owners may contact Chevrolet at 1-800-630-2438 and Gmc at 1-866-996-9463 or at the owner center at www.gmownercenter.com.

• NHTSA recall #09V491000December 23, 200922,090 vehicles affected

  structure: body: roof and pillars

  General motors is recalling certain model year 2005 through 2007 Corvette vehicles equipped with a removable roof and model year 2006 and 2007 Corvette Z06 vehicles. The adhesive between the roof panel and the frame may separate. If there is a partial separation, the driver may notice one or more symptoms, such as a snapping noise when driving over bumps, wind noise, poor roof panel fit, roof panel movement/bounce when a door or hatch is closed, or a water leak in the headliner.

  If there is a complete separation, the roof panel may detach from the vehicle. If this were to occur while the vehicle was being driven, it could strike a following vehicle and cause injury and/or property damage.

  Remedy

  Dealers will install a new design roof panel free of charge. The safety recall is expected to begin during april 2010. Owners may contact Chevrolet at 1-800-630-2438 or at www.gmownercenter.com.

• NHTSA recall #06V181000May 24, 200630,793 vehicles affected

  structure: body: roof and pillars

  On certain 2005-2006 Chevrolet corvettes equipped with painted roofs, the adhesive between the roof panel and the frame may separate.

  If there is a complete separation, the roof panel may detach from the vehicle and it could strike another vehicle and cause injury and property damage.

  Remedy

  Dealers will inspect vehicles free of charge for potential roof panel-to- frame separation and add the specified adhesive foam or replace the roof with one having adhesive foam. The recall began on october 19, 2006. Owners may contact Chevrolet at 1-800-630-2438.

• NHTSA recall #05V455000October 5, 2005123,592 vehicles affected

  steering: hydraulic power assist: hose, piping, and connections

  Certain passenger vehicles may have been built with a power steering hose that is not to specification. Under extreme steering maneuvers, such as turning the steering wheel fully to the left or right while braking, the hose may fracture and leak fluid.

  If this were to occur, power steering assist would be lost and increased steering effort would be required. On vehicles equipped with hydro-boost power brakes, it could also result in loss of power brake assist and increased braking effort would be required. If the power steering fluid spray were to spray onto hot engine parts, an engine compartment fire could occur.

  Remedy

  Dealers will inspect the power steering hose(s) for two suspect date codes and replace them if required. The recall will begin on october 14, 2005. Owners may contact Chevrolet at 1-800-630-2438, Gmc at 1-866-996-9463, Buick at 1-866-608-8080, Cadillac at 1-866-982-2339, Isuzu at 1-800-255-6727, or Hummer at 1-800-732-5493.

Other model years

• 1990 34
• 1994 29
• 1995 32
• 1996 44
• 1997 153
• 1998 399
• 1999 308
• 2000 278
• 2001 205
• 2002 157
• 2003 85
• 2004 217
• 2005 533
• 2006
• 2007 341
• 2008 541
• 2009 151
• 2010 84
• 2011 85
• 2012 56
• 2013 82
• 2014 63
• 2015 65
• 2016 104
• 2017 257
• 2018 51
• 2019 148
• 2020 34
• 2023 27