2004 Isuzu Rodeo

Complaint history

When NHTSA received these reports. Changes in reporting alone do not establish a change in failure rates.

Problems owners report

Listed groups have at least 3 complaints. The page includes the 20 largest groups plus any additional flagged groups; some complaints are not assigned to a group.

AI groups complaints by meaning; the groups are approximate. Share ratio compares the problem’s share of this vehicle’s complaints with its share on other vehicles over the last 24 months (shown from 3 recent complaints). A 2× ratio means twice the complaint share, not twice the failure risk. Flags mark unusual shares or recent surges after an AI review of the complaint content. “First signal” does not mean the pattern has persisted continuously.How recall estimates are calculated.

Recalls

• NHTSA recall #13V547000October 31, 20138,816 vehicles affected

  suspension: rear

  Isuzu Manufacturing Services of America, Inc (Isuzu) is recalling certain model year 2003-2004 Rodeo and Axiom, and 2003 Rodeo Sport vehicles that were originally sold in, or are currently registered in, Maine, New Hampshire, Vermont, Massachusetts, Rhode Island, Connecticut, New York, New Jersey, Pennsylvania, Delaware, Maryland, the District of Columbia, West Virginia, Ohio, Indiana, Michigan, Illinois, Wisconsin, Minnesota, Iowa, Kentucky and Missouri. These vehicles may experience excessive corrosion near the forward mounting point bracket for the left or right rear suspension lower link.

  The corrosion may allow the bracket to detach from the frame, impacting vehicle handling and increasing the risk of a crash.

  Remedy

  Isuzu will notify owners, and dealers will inspect the rear suspension lower link bracket area. For vehicles in which little or no corrosion is found, the area will be treated with an anti-corrosive compound. For vehicles in which corrosion has damaged the rear suspension lower link bracket and affected its connection to the vehicle frame, a reinforcement bracket will be installed. In the event the corrosion is so severe that the reinforcement bracket remedy would not be sufficient, Isuzu will offer to repurchase the vehicle for an amount based on the Kelley Blue Book "Private Party" price. All inspections and remedies will be provided free of charge for vehicles that are 10 years old or less. For vehicles older than 10 years, Isuzu will offer a free remedy, but only if the vehicle is presented to an Isuzu service facility dealer within 12 months of when owner notifications were issued, after that time owners will be charged for the repairs. The recall is expected to begin in mid-December 2013. Isuzu owners may contact Isuzu at 1-800-255-6727.

• NHTSA recall #05V466000October 7, 200515,515 vehicles affected

  fuel system, gasoline: delivery: fuel pump

  Certain sport utility vehicles that have been exposed to fuel contaminated with silicon may develop small pin holes in the fuel pump feed port. Silicon has been identified in the fuel systems of affected vehicles and in certain fuel available in the region of tyler, texas. This recall will be launched for vehicles registered in texas and the four surrounding states: oklahoma, arkansas, new mexico and louisiana.

  A fuel leak could lead to a vehicle fire.

  Remedy

  For vehicles registered in the states identified above, dealers will provide a new cover over the existing feed port on the fuel pump or, if the existing feed port has already been damaged, dealers will install a new fuel pump that is equipped with the new cover. The new cover will be made of a different material. The recall began on november 25, 2005. Owners may contact Isuzu at 1-800-255-6727.

Other model years

• 1991 42
• 1992 80
• 1993 34
• 1994 82
• 1995 176
• 1996 97
• 1997 118
• 1998 478
• 1999 550
• 2000 274
• 2001 389
• 2002 101
• 2004