1996 Ford Contour

Complaint history

When NHTSA received these reports. Changes in reporting alone do not establish a change in failure rates.

Problems owners report

Listed groups have at least 3 complaints. The page includes the 20 largest groups plus any additional flagged groups; some complaints are not assigned to a group.

AI groups complaints by meaning; the groups are approximate. Share ratio compares the problem’s share of this vehicle’s complaints with its share on other vehicles over the last 24 months (shown from 3 recent complaints). A 2× ratio means twice the complaint share, not twice the failure risk. Flags mark unusual shares or recent surges after an AI review of the complaint content. “First signal” does not mean the pattern has persisted continuously.How recall estimates are calculated.

Recalls

• NHTSA recall #01V230000July 9, 2001342,962 vehicles affected

  electrical system

  On certain my 1996-1998 passenger vehicles built at the kansas city, cuautitlan assembly plants or on my 1999 passenger vehcles built at the automotive alliance international assembly plants, the rough surface of the heater blower resistor's stainless steel blades Can damage the copper surface of the wiring harness connector. The damage could, over time, cause increased resistance in the connector and, due to subsequent terminal relaxation, result in an open circuit condition.

  The open circuit could lead to electrical arcing that could melt the connector housing material creasing the potential for a fire.

  Remedy

  Dealers will install a new heater blower resistor and a new wire jumper harness. Owner notification began august 29, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact Ford at 1-800-392-3673.

• NHTSA recall #00V367000November 6, 2000262,559 vehicles affected

  engine and engine cooling

  Vehicle description: 1995 passenger vehicles equipped with the 2.0L and 2.5L engines, and 1996 vehicles equipped with 2.5L engines. Tightening of the engine cooling fan motor bearings, up to and including motor stall, Can result in increased motor torque and higher than normal motor current and accompanying high motor temperatures.

  Overheating of the cooling fan motor due to excessive current Can result in smoke and odors from bearing grease, insulation and other internal motor components. If electrical current continues to be applied to the motor, internal motor components could ignite possibly igniting other engine compartment components.

  Remedy

  Dealers will install a positive temperature coefficient device in-line with each fan motor. Ford will also extend the warranty on the engine cooling fan assembly to a total of 8 years of service or 100,000 miles from the warranty start date, whichever occurs first. If the vehicle already has more than 100,000 miles, this coverage will last until july 31, 2001.

• NHTSA recall #00V075000March 9, 2000436,200 vehicles affected

  service brakes, hydraulic: foundation components

  Vehicle description: passenger vehicles not equipped with the anti-lock braking system (ABS). A pressure conscious reducing valve (pcrv) in the rear brakes may be subject to corrosion and result in malfunction, when operated in areas that use salt compounds on the roadway for de-icing or dust control.

  If both pcrv's malfunction, vehicle handling could be adversely affected during braking as a result of the rear wheels locking, increasing the risk of a crash.

  Remedy

  Dealers will install improved pcrv's in the rear brake system. This recall was expanded in september 2000 to include 1999 and 2000 Ford Contour, mercury mystique and cougar vehicles.

• NHTSA recall #99V247000September 13, 199922,324 vehicles affected

  fuel system, gasoline: storage: tank assembly: filler pipe and cap

  Vehicle description: passenger vehicles. The fuel filler pipe vent hose may have less than the intended level of ozone resistance, which could result in the hose becoming brittle and cracking.

  A cracked hose could result in fuel leakage when the vehicle is being fueled.

  Remedy

  Dealers will install a fuel filler vent hose contacting the appropriate blend of pvc and nitrile rubber.

• NHTSA recall #99V103000May 5, 1999605,581 vehicles affected

  exterior lighting: headlights: switch

  Vehicle description: passenger vehicles. The terminals at the headlight switch and wiring harness connector Can experience heat damage as a result of overheating.

  The damage could result in distortion of the terminal causing an open circuit in the instrument panel illumination, parking lamp, and tail lamp circuits.

  Remedy

  Dealers will install a headlamp switch wiring connector containing bronze terminals and an inspection, and replacement if necessary, of the headlamp switch.

• NHTSA recall #98V233000September 18, 1998175,000 vehicles affected

  power train: automatic transmission: lever and linkage: floor shift

  Vehicle description: passenger vehicles. The floor shift automatic transmission control Can be damaged if subjected to certain interior cleaning products. The gear position indicator Can deteriorate and not correctly indicate the actual gear position.

  This condition Can result in incorrect gear selection.

  Remedy

  Dealers will replace the automatic transmission floor shift control.

• NHTSA recall #97V225000December 8, 199738,000 vehicles affected

  vehicle speed control: cables

  Vehicle description: passenger vehicles equipped with the traction control option. The throttle cables were damaged during vehicle assembly leading to fraying or separation of the throttle cable.

  This condition could prevent the engine from returning to idle.

  Remedy

  Dealers will replace the throttle cable with a revised design that is less susceptible to bending or kinking during installation.

• NHTSA recall #97V203000November 17, 19971,800 vehicles affected

  fuel system, other: storage

  Vehicle description: bi-fuel vehicles modified to run on either gasoline or compressed natural gas (cng). The natural gas fuel tanks have a solenoid shut-off valve that stops fuel flow from the fuel tank in the event of certain moderate to severe collisions. If the vehicle is in a collision and the natural gas fuel line is damaged, the system could leak natural gas.

  Fuel leakage in the presence of an ignition source could result in a fire.

  Remedy

  Ford has requested owners of these vehicles to have the cng fuel system disabled under a previous recall campaign and to only use gasoline fuel until a permanent corrective action is developed. Owners are being alerted to this solenoid valve concern at this time. The timing of corrective actions is being delayed to allow both conditions to be remedied at one time. In the meantime, there is not risk as long as the natural gas system has been disabled and the vheicle is only operated on gasoline.

Other model years

• 1995 891
• 1996
• 1997 218
• 1998 846
• 1999 419
• 2000 199