1996 Dodge RAM

Complaint history

When NHTSA received these reports. Changes in reporting alone do not establish a change in failure rates.

Problems owners report

Listed groups have at least 3 complaints. The page includes the 20 largest groups plus any additional flagged groups; some complaints are not assigned to a group.

AI groups complaints by meaning; the groups are approximate. Share ratio compares the problem’s share of this vehicle’s complaints with its share on other vehicles over the last 24 months (shown from 3 recent complaints). A 2× ratio means twice the complaint share, not twice the failure risk. Flags mark unusual shares or recent surges after an AI review of the complaint content. “First signal” does not mean the pattern has persisted continuously.How recall estimates are calculated.

Recalls

• NHTSA recall #01V037000February 12, 2001157,000 vehicles affected

  vehicle speed control

  Vehicle description: pickup trucks equipped with diesel engines. The throttle cable could unravel (fray) or break resulting in loss of throttle control.

  A throttle that does not return to idle could result in unexpected acceleration, increasing the risk of a crash.

  Remedy

  Dealers will inspect and replace the throttle cable and upper bell crank lever. Owner notification began august 3, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403.

• NHTSA recall #01V040000February 12, 2001701,000 vehicles affected

  latches/locks/linkages: hood: latch

  On certain pickup trucks originally sold in or currently registered in the following "salt belt" states: maine, new hampshire, vermont, massachusetts, rhode island, connecticut, new york, new jersey, pennsylvania, delaware, maryland, the district of columbia, west virginia, ohio, indiana, michigan, illinois, wisconsin, minnesota, iowa, and missouri. Corrosion of the return spring on the hood secondary latch could cause the mechanism to bind in the "release position."

  If the primary latch is not engaged, the hood could open unexpectedly.

  Remedy

  Dealers will replace the secondary hood latch. Owner notification began september 17, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403.

• NHTSA recall #00V135000May 10, 2000690,000 vehicles affected

  electrical system: ignition: switch

  Vehicle description: light duty pickup trucks. The affected vehicles were built with an ignition switch and wiring that could overheat. High electrical current loads pass through the switch when the blower motor is operated on high for an extended periods of time.

  This could cause the ignition switch and wiring to overheat.

  Remedy

  Dealers will install a relay and overlay harness.

• NHTSA recall #99V115000May 6, 19998,883 vehicles affected

  power train: clutch assembly

  Vehicle description: pickup trucks equipped with manual transmission, V10 engines and four-wheel-drive transfer cases. Under sustained maximum rated vehicle load, while driving up a steep grade in four-wheel-drive low range in hot ambient conditions, the local exhaust temperature proximate to the hydraulic clutch line Can generate line temperatures that exceed the temperature limit of the clutch line material. If this condition occurs and the clutch is depressed, the line could rupture.

  The fluid could ignite on the hot exhaust possibly resulting in a vehicle fire.

  Remedy

  Dealers will replace the hydraulic clutch assembly.

• NHTSA recall #99V023000February 5, 1999250,845 vehicles affected

  air bags: frontal

  Vehicle description: van and wagon model passenger vehicles. If water/road salt gets on the interior floor of the vehicle in the proximity of the air bag electronic control module (aecm), the aecm Can corrode. The resulting corrosion Can cause the driver side air bag to deploy inadvertently.

  Deployment of the air bag without warning could cause a driver to lose vehicle control, increasing the risk of a crash and personal injury.

  Remedy

  Dealers wil replace the aecm with an aecm that is sealed from moisture intrusion.

• NHTSA recall #97V199000November 13, 1997497,000 vehicles affected

  fuel system, gasoline: delivery: hoses, lines/piping, and fittings

  Vehicle description: light duty pickup trucks equipped with gasoline engines. The fuel tank mounted rollover valve Can allow liquid fuel to leak onto the ground under certain vehicle operating conditions.

  Fuel leakage could result in a fire if an ignition source was present.

  Remedy

  Dealers will replace the fuel tank rollover valve with a float type rollover valve.

• NHTSA recall #97V084000May 5, 1997960,000 vehicles affected

  power train: automatic transmission: cooling unit and lines

  Under certain high load operating conditions, the transmission fluid temperature Can exceed the melting point of the material used in the connector to retain the fluid line to the transmission.

  When these temperatures occur, the fluid line will not stay connected with the transmission and fluid Can spray onto the exhaust manifold, resulting in smoke or fire.

  Remedy

  Dealers will replace the high temperature side of the transmission fluid cooler line connector fittings with connectors that incorporate a stainless steel retainer.

• NHTSA recall #97V068000April 28, 199758,000 vehicles affected

  service brakes, hydraulic: power assist: vacuum: hoses, lines/piping, and fittings

  Vehicle description: pickup trucks equipped with diesel engines. The engine driven vacuum pump Can allow engine oil into the vacuum hoses due to the absence of an internal check valve. The oil Can cause the hose to deteriorate and partially collapse, reducing the vacuum supply to the brake booster.

  Reduced power brake assist Can result increasing the risk of a vehicle crash.

  Remedy

  Dealers will add a vacuum pump check valve to the vacuum pump. In addition, the vacuum hose connected to the vacuum pump will be replaced with a hose that is engine oil resistant.

• NHTSA recall #96V027000February 5, 19962,500 vehicles affected

  equipment: other: labels

  The involved vehicles have tire/wheel specification information on the vehicle certification label which indicates a smaller size tire than required. This does not comply with label requirements of FMVSS no. 120, "tire selection and rims for motor vehicles other than passenger cars."

  Consequence of non-compliance: the smaller tires would not have sufficient load capacity for the vehicles specified gross weight rating, increasing the potential for a premature tire failure and an accident.

  Remedy

  Owners will be mailed an overlay label with the correct tire/wheel certification information and instructions for installing the label on their vehicles. If owners prefer, their dealer Can install the label for them.

• NHTSA recall #95V237000December 12, 199512,000 vehicles affected

  electrical system: alternator/generator/regulator

  The fasteners which secure the generator cartridge fuse to the power distribution center may have an improper clamp load. Improper clamping Can result in arcing at the connection.

  This condition Can potentially cause a fire in the engine compartment.

  Remedy

  Dealers will tighten the generator cartridge fuse fasteners properly.

Other model years

• 1989 28
• 1991 51
• 1992 58
• 1993 54
• 1994 469
• 1995 611
• 1996
• 1997 398
• 1998 483
• 1999 366
• 2000 147
• 2001 318
• 2002 116
• 2003 53
• 2004 58
• 2005 40
• 2006 25
• 2008 25
• 2010 27