2007 Dodge RAM 2500

Complaint history

When NHTSA received these reports. Changes in reporting alone do not establish a change in failure rates.

Problems owners report

Listed groups have at least 3 complaints. The page includes the 20 largest groups plus any additional flagged groups; some complaints are not assigned to a group.

AI groups complaints by meaning; the groups are approximate. Share ratio compares the problem’s share of this vehicle’s complaints with its share on other vehicles over the last 24 months (shown from 3 recent complaints). A 2× ratio means twice the complaint share, not twice the failure risk. Flags mark unusual shares or recent surges after an AI review of the complaint content. “First signal” does not mean the pattern has persisted continuously.How recall estimates are calculated.

Recalls

• NHTSA recall #16V352000May 24, 20164,648,270 vehicles affected

  Do not drive: NHTSA advises this until the repair is done.

  air bags: frontal: passenger side: inflator module

  Chrysler (FCA US LLC) expanded the affected population to include 73,712 2005-2009 RAM 2500 trucks produced at the St. Louis North Assembly Plant. With this change, Chrysler is recalling certain model year 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2010 RAM 3500 Cab Chassis, 2008-2010 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2012 Jeep Wrangler, 2008-2012 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2012 Chrysler 300, 2006-2012 Dodge Charger, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AL, CA, FL, GA, HI, LA, MS, SC, TX, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Chrysler is also recalling 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2009 RAM 3500 Cab Chassis, 2008-2009 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2009 Jeep Wrangler, 2008-2009 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2009 Chrysler 300, 2006-2009 Dodge Charger, 2005-2009 Dodge Dakota and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AZ, AR, DE, Washington D.C., IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Chrysler is recalling certain 2005-2008 RAM 2500, 2006-2008 RAM 3500, 2007-2008 RAM 3500 Cab Chassis, 2008 RAM 4500 and 5500 Cab Chassis, 2004-2008 Dodge Durango, 2007-2008 Chrysler Aspen, 2007-2008 Jeep Wrangler, 2008 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2008 Chrysler 300, 2006-2008 Dodge Charger, 2005-2008 Dodge Dakota, and 2006-2008 Mitsubishi Raider vehicles originally sold, or registered, in AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY.

  These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. These inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling. An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

  Remedy

  Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify the Chrysler, Dodge, Jeep and RAM owners. Mitsubishi owners will be notified by their company. Dealers will replace the passenger frontal air bag inflator, free of charge. The recall began on March 27, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S43. Note: This recall supersedes recall 14V-7700.

• NHTSA recall #15V313000May 26, 20154,077,169 vehicles affected

  Do not drive: NHTSA advises this until the repair is done.

  air bags: frontal: driver side: inflator module

  Chrysler (FCA US LLC) is recalling certain model year 2005-2009 Dodge Ram 2500, 2004-2008 Dodge Ram 1500 and Durango, 2006-2009 Dodge Ram 3500, 2008-2010 Dodge Ram 4500 and 5500, 2007-2008 Chrysler Aspen, 2005-2010 Chrysler 300, 300C, 300S, and SRT8, 2006-2010 Dodge Charger, 2005-2008 Magnum, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.

  In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.

  Remedy

  Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify the affected Chrysler and Dodge owners and Mitsubishi will notify the affected Raider owners. Dealers will replace the driver's frontal air bag inflator, free of charge. The recall began for Chrylser on June 8, 2015. The recall for Mitsubishi started on June 24, 2015. Chrysler and Dodge owners may contact Chrysler customer service at 1-800-853-1403. Mitsubishi owners may call 1-888-648-7820. Chrysler's number for this recall is R25. Note: This recall supersedes recall 14V817 in its entirety. Vehicles that have had their driver side frontal air bag replaced previously need to have their air bag replaced under this recall as well.

• NHTSA recall #14V795000December 16, 201454,164 vehicles affected

  electrical system: ignition: switch

  Chrysler Group LLC (Chrysler) is recalling certain model year 2006-2007 Dodge Ram 1500, 2500, 3500, Dakota, and 2006 Mitsubishi Raider vehicles manufactured July 1, 2005, to July 31, 2006 with manual transmissions. The return springs in the clutch ignition interlock switch may break.

  Broken springs can result in a no-start condition, or cause unintended movement when the ignition is cranked, increasing the risk of a vehicle crash.

  Remedy

  Chrysler will notify owners, and dealers will replace the clutch ignition interlock switch, free of charge. The recall began on March 27, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P80.

• NHTSA recall #13V528000November 6, 2013706,664 vehicles affected

  steering: linkages: tie rod assembly

  Chrysler Group LLC (Chrysler) is recalling certain model year 2003-2008 Dodge RAM 2500 4x4 and 3500 4x4, model year 2007-2008 Dodge RAM 3500 4x2 Cab Chassis and model year 2006-2008 Dodge RAM 1500 Mega Cab 4x4 trucks manufactured February 12, 2002, through February 13, 2008. The left tie rod assembly may break.

  A failure of the tie rod assembly may result in a loss of steering control, increasing the risk of a crash.

  Remedy

  Chrysler notified owners and launched its recall campaign in January 2014. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N62.

• NHTSA recall #11V350000July 6, 2011242,780 vehicles affected

  steering: linkages: tie rod assembly

  Chrysler is recalling certain model year 2008-2011 Dodge Ram 2500/3500 4X4, manufactured from february 14, 2008, through march 28, 2011; model year 2008-2011 Dodge Ram 3500 cab chassis 4X2, manufactured from february 14, 2008, through march 28, 2011; and model year 2008 Dodge Ram 1500 mega cab 4X4, manufactured from february 14, 2008, through august 15, 2008, because the left tie rod ball stud may fracture. This condition tends to occur during low speed parking lot type maneuvers when the customer is making a tight turn. Additionally, model year 2003-2008 Dodge Ram 2500/3500 vehicles may have received the affected tie rod assembly as a replacement part during normal service.

  This condition could result in the potential loss of directional stability in the left hand front wheel, increasing the risk of a crash.

  Remedy

  Dealers will inspect the tie rod ends for relative orientation and replace the left outer tie rod as required and perform a front end toe alignment as needed. This service will be performed free of charge. The safety recall began on october 3, 2011. Owners may contact Chrysler at 1-800-853-1403.

• NHTSA recall #08V641000December 5, 2008108,429 vehicles affected

  engine and engine cooling: engine: diesel

  Chrysler is recalling 108,429 my 2007-2008 Dodge Ram 2500 and 3500 pickup trucks equipped with 6.7L diesel engines. A silencer pad Can sag and contact the exhaust gas recirculation (egr) cooler.

  This could result in an engine compartment fire.

  Remedy

  Dealers will add a bracket to support the engine compartment silencer pad adjacent to the egr cooler. The recall is expected to begin during december 2008. Owners may contact Chrysler at 1-800-853-1403.

• NHTSA recall #07V247000June 13, 20075,062 vehicles affected

  fuel system, gasoline: storage

  Certain pickup trucks equipped with 34 gallon fuel tanks fail to comply with the requirements of federal motor vehicle safety standard no. 301, "fuel system integrity." the fuel tank may become damaged during certain crash conditions, which could allow fuel leakage to occur if the vehicle rolls over.

  Fuel leakage, in the presence of an ignition source, could result in a fire.

  Remedy

  Dealers will install a fuel tank shield onto the front frame cross member. The recall began on june 12, 2007. Owners may contact daimlerchrysler at 1-800-853-1403.

• NHTSA recall #07V093000March 12, 20073,282 vehicles affected

  equipment: other: labels

  Certain 4X4 trucks with diesel engines fail to conform to the requirements of federal motor vehicle safety standard no. 120, certain 4X4 trucks with diesel engines fail to conform to the requirements of federal motor vehicle safety standard no. 120, "tire selection and rims for motor vehicles other than passenger cars." the certification label, tire and loading information label and supplemental tire pressure information label contain incorrect tire inflation pressure information.

  Improper tire inflation pressure Can cause tire failure and result in a crash without warning.

  Remedy

  Dealers will install the correct certification label overlay free of charge. The recall began on march 12, 2007. Owners may contact daimlerchryler at 1-800-853-1403.

Other model years

• 1992 32
• 1993 39
• 1994 168
• 1995 267
• 1996 291
• 1997 213
• 1998 225
• 1999 313
• 2000 211
• 2001 469
• 2002 155
• 2003 661
• 2004 582
• 2005 422
• 2006 670
• 2007
• 2008 317
• 2009 214
• 2010 236
• 2011 298
• 2012 283