2006 Toyota Tacoma

Complaint history

When NHTSA received these reports. Changes in reporting alone do not establish a change in failure rates.

Problems owners report

Listed groups have at least 3 complaints. The page includes the 20 largest groups plus any additional flagged groups; some complaints are not assigned to a group.

AI groups complaints by meaning; the groups are approximate. Share ratio compares the problem’s share of this vehicle’s complaints with its share on other vehicles over the last 24 months (shown from 3 recent complaints). A 2× ratio means twice the complaint share, not twice the failure risk. Flags mark unusual shares or recent surges after an AI review of the complaint content. “First signal” does not mean the pattern has persisted continuously.How recall estimates are calculated.

Recalls

• NHTSA recall #16V396000June 2, 20167,749 vehicles affected

  seats: front assembly: seat heater/cooler

  Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.

  If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.

  Remedy

  SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.

• NHTSA recall #14V743000November 19, 20143,233 vehicles affected

  seats: front assembly: seat heater/cooler

  Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.

  Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.

  Remedy

  SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.

• NHTSA recall #14V604000September 29, 2014710,711 vehicles affected

  suspension: rear: springs: leaf spring assembly: leaf

  Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2005-2011 Toyota Tacoma Pre-Runner and 4x4 vehicles manufactured September 14, 2009, to October 11, 2010. In the affected vehicles, one of the leaf springs may fracture due to stress or corrosion. While being driven, the broken leaf could move out of position and contact surrounding components including the fuel tank, possibly puncturing the tank and causing a fuel leak.

  If the fuel tank leaks fuel from being punctured, there is an increased risk of a fire.

  Remedy

  Toyota will notify owners and dealers will install new rear leaf spring assemblies. The recall began on January 29, 2016. Owners may contact Toyota customer service at 1-800-331-4331.

• NHTSA recall #13V337000August 7, 2013342,451 vehicles affected

  seat belts

  Toyota is recalling certain model year 2005-2010 Tacoma Access Cab vehicles manufactured September 14, 2004, through March 29, 2010; and model year 2011 Tacoma Access Cab vehicles manufactured July 1, 2010, through September 7, 2011. If the access doors are repeatedly and forcefully closed, the screws that attach the seat belt pre-tensioner to the seat belt retractor can loosen over time. If the screws loosen completely, the seat belt pre-tensioner and the retractor spring cover could detach from the seat belt retractor.

  If the seat belt pre-tensioner detaches from the seat belt assembly, the seat belt pre-tensioner will not perform as designed, increasing the risk of injury in a severe crash.

  Remedy

  Toyota will notify owners, and dealers will inspect the seat belt assemblies. Based on the inspection, the seat belt assembly will be replaced or new pre-tensioner screws will be installed with thread-locking sealant and a retractor spring cover with stopper ribs to prevent loosening of the screws. These services will be provided at no cost to the owner. The recall began during February 2014. Owners may contact Toyota at 1-800-331-4331.

• NHTSA recall #12V092000March 7, 2012495,470 vehicles affected

  air bags: frontal

  Toyota is recalling certain model year 2005-2009 Tacoma vehicles, manufactured from september 14, 2004, through august 29, 2008. Over time, steering wheel vibration may damage the spiral cable assembly (clockspring) that powers the driver’s air bag module. If damage occurs, the air bag warning lamp will illuminate and the air bag may become deactivated.

  In the event of a crash, the driver’s side air bag may not deploy, increasing the risk of personal injury.

  Remedy

  Toyota will notify owners, and dealers will replace the spiral cable assembly, free of charge. An interim letter is expected to be mailed to owners during april 2012. Owners may contact Toyota at 1-800-331-4331.

• NHTSA recall #10V035000February 3, 2010271,417 vehicles affected

  equipment: other: labels

  Gulf states Toyota is recalling certain model year 2005-2010 vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims." these vehicles were sold between september 1, 2005 and june 2, 2008 without the requisite load carrying capacity modification labels.

  This does not meet the standard requirements.

  Remedy

  Dealers will mail to consumers the corrected label or the customer will have the option for dealers to install the label free of charge. Dealers will also correct the owner's manual. The safety recall began on may 27, 2010. Owners may contact gulf states Toyota at 713-580-3300.

• NHTSA recall #10V036000February 3, 2010153,418 vehicles affected

  equipment: other: labels

  Southeast Toyota is recalling certain model year 2005-2011 passenger vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims." these vehicles were sold without the requisite load carrying capacity modification labels.

  A driver may overload a vehicle which may increase the risk of a crash.

  Remedy

  Dealers will mail to consumers the corrected label or the customer will have the option for dealers to install the label free of charge. The safety recall began on may 27, 2010. Owners may contact southeast Toyota at 1-800-301-6859.

• NHTSA recall #09V388000October 5, 20094,445,056 vehicles affected

  vehicle speed control: accelerator pedal

  Toyota is recalling certain model year 2004-2010 passenger vehicles. The accelerator pedal Can get stuck in the wide open position due to its being trapped by an unsecured or incompatible driver's floor mat.

  A stuck open accelerator pedal may result in very high vehicle speeds and make it difficult to stop the vehicle, which could cause a crash, serious injury or death.

  Remedy

  Toyota filed an amended defect report on november 25, 2009, stating that dealers will modify the accelerator pedal and, on certain vehicles, alter the shape of the floor surface under the pedal. These changes address the risk of pedal entrapment due to interference with the floor mat. Redesigned accelerator pedals will become available beginning in april 2010 and dealers will replace any modified pedal with the new pedal if desired. Also, dealers will replace any genuine Toyota or Lexus all-weather floor mats with redesigned all-weather mats, or repurchase the previous mats from owners who do not want the new ones. Additionally, software modifications will be installed on camry, avalon and Lexus es 350, is 350 and is 250 models that will ensure that the brake overrides the accelerator in the event both brake and accelerator pedals are applied. Toyota will begin mailing letters to owners on december 31, 2009. Owners may contact Toyota at 1-800-331-4331, Lexus at 1-800-255-3987.

• NHTSA recall #09V223000June 15, 200927,080 vehicles affected

  equipment: other: labels

  Toyota is recalling 27,080 model year 2005 through 2010 passenger cars built from september 1, 2005 to may 4, 2009. These vehicles were not equipped with load carrying capacity modification labels which fails to conform with the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims."

  Incorrect load carrying capacity modification labels could result in the vehicle being overloaded, increasing the risk of a crash.

  Remedy

  Toyota will notify owners and provide them with a new, accurate label to be installed over the inaccurate label free of charge. The safety recall began on august 18, 2009. Owners may contact Toyota at 1-888-270-9371.

• NHTSA recall #06V096000April 3, 2006133 vehicles affected

  air bags

  On certain vehicles, due to improper assembly of the air bag inflator, which is used in the side air bag, the curtain shield air bag, and the knee air bag assembly, some inflators were produced with an insufficient amount of the heating agents necessary for proper air bag deployment. In this condition, the expansion force of the gas may be insufficient to properly inflate the air bag when the SRS system is activated during a crash.

  This may increase the risk of injury to the occupant in the involved seating position in the event of a crash.

  Remedy

  Dealers will replace the specific SRS air bag. The recall began on april 6, 2006. Owners may contact Toyota at 1-888-270-9371, Scion at 1-866-548-1851, or Lexus at 1-800-255-3987.

• NHTSA recall #06V061000March 2, 200612,020 vehicles affected

  tires: bead

  On certain pickup trucks, the bead of the tire may be damaged due to improper assembly of the tires onto the wheels.

  If the vehicle is operated in this condition, there is a possibility that a bulge may be formed on the sidewall and air may leak from the area of the damaged bead and a crash could occur.

  Remedy

  Dealers will inspect the tires and replace if necessary free of charge. The recall began on march 27, 2006. Owners may contact Toyota at 1-800-331-4331.

Other model years

• 1995 177
• 1996 253
• 1997 131
• 1998 300
• 1999 249
• 2000 211
• 2001 396
• 2002 333
• 2003 360
• 2004 415
• 2005 707
• 2006
• 2007 541
• 2008 449
• 2009 519
• 2010 294
• 2011 186
• 2012 295
• 2013 125
• 2014 93
• 2015 101
• 2016 324
• 2017 243
• 2018 209
• 2019 219
• 2020 90
• 2021 81
• 2022 59
• 2023 54
• 2024 154
• 2025 114