2016 Mercedes-Benz Sprinter 3500

Complaint history

When NHTSA received these reports. Changes in reporting alone do not establish a change in failure rates.

Problems owners report

Listed groups have at least 3 complaints. The page includes the 20 largest groups plus any additional flagged groups; some complaints are not assigned to a group.

AI groups complaints by meaning; the groups are approximate. Share ratio compares the problem’s share of this vehicle’s complaints with its share on other vehicles over the last 24 months (shown from 3 recent complaints). A 2× ratio means twice the complaint share, not twice the failure risk. Flags mark unusual shares or recent surges after an AI review of the complaint content. “First signal” does not mean the pattern has persisted continuously.How recall estimates are calculated.

Recalls

• NHTSA recall #21V042000February 3, 202148,667 vehicles affected

  electronic stability control (esc): control module

  Daimler Vans USA, LLC (DVUSA) is recalling certain 2012-2018 Mercedes Benz Sprinter 3500 and Freightliner Sprinter 3500 vehicles upfitted into campers or recreational vehicles. The Electronic Stability Control (ESC) unit may become disabled on these vehicles.

  If ESC becomes disabled, vehicle driving stability may be impacted under certain driving conditions, increasing the risk of a crash.

  Remedy

  DVUSA will notify owners, and dealers will replace the rear-wheel speed sensor with a more robust sensor, free of charge. DVUSA issued owners an interim notification on March 10, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is NC3DREZAHA.

• NHTSA recall #20V663000October 28, 202047,667 vehicles affected

  steering: hydraulic power assist: hose, piping, and connections

  Daimler Vans USA, LLC (DVUSA) is recalling certain 2015-2020 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The hydraulic power steering return line hoses may detach at their connection points under certain operating conditions, causing hydraulic fluid to leak.

  The sudden loss of power steering assist and hydraulic steering fluid leaking onto the roadway may increase the risk of a crash.

  Remedy

  DVUSA will notify owners, and dealers will check the return line connections of the power steering system, correcting it as needed, free of charge. The recall began December 23, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this campaign is NV3LETULPE.

• NHTSA recall #19V003000January 8, 201971,301 vehicles affected

  air bags: frontal: driver side: inflator module

  Daimler Vans USA, LLC (DVUSA) is recalling certain 2015-2017 Freightliner Sprinter 2500 and 3500 and Mercedes-Benz Sprinter 2500 and 3500 vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the driver frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the driver frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

  An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

  Remedy

  DVUSA will notify owners, and dealers will replace the front driver air bag module, free of charge. The recall is began March 15, 2019. Owners may contact DVUSA customer service at 1-877-762-8267.

• NHTSA recall #19V004000January 8, 201988,388 vehicles affected

  air bags: frontal: passenger side: inflator module

  Daimler Vans USA, LLC (DVUSA) is recalling certain 2014-2017 Freightliner Sprinter 2500 and 3500 and Mercedes-Benz Sprinter 2500 and 3500 vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

  An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

  Remedy

  DVUSA will notify owners, and dealers will replace the front passenger air bag module, free of charge. The recall began March 15, 2019. Owners may contact DVUSA customer service at 1-877-762-8267.

• NHTSA recall #18V113000February 15, 201817 vehicles affected

  equipment: other: labels

  Daimler Vans USA, LLC (DVUSA) is recalling certain 2016-2017 Mercedes-Benz Sprinter 2500 and Sprinter 3500 vehicles, equipped with folding seats (sales code S20). The unloaded vehicle weight (UVW) label on these incomplete vehicles may be incorrect.

  The incorrect UVW label can result in final stage manufacturers exceeding the maximum vehicle weight once the vehicle is completed. A vehicle that exceeds its maximum weight has an increased risk of a crash.

  Remedy

  DVUSA will notify owners, and dealers will replace the UVW label and inspect the vehicle to make sure that it is not overloaded, free of charge. The recall began on April 3, 2018. Owners may contact DVUSA customer service at 1-877-762-8267.

• NHTSA recall #17V786000December 8, 2017550 vehicles affected

  equipment

  Midwest Automotive Designs, LLC (Midwest) is recalling certain Custom Vans and Camper Van recreational vehicles built on 2014-2017 Mercedes Benz Sprinter chassis and 2016-2017 RAM Promaster chassis. These vehicles are equipped with Kidde Plastic-Handle or Push Button 'Pindicator' fire extinguishers that may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

  In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

  Remedy

  Midwest will notify owners, and dealers will replace the fire extinguisher with a different brand, free of charge. The recall began on December 11, 2017. Owners may contact Kidde customer service for their replacement extinguisher at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information.

• NHTSA recall #17V650000October 16, 20172 vehicles affected

  equipment: other: labels

  Daimler Vans USA, LLC (DVUSA) is recalling certain 2016 Mercedes-Benz Sprinter 2500 and 3500 vehicles. The label on the B-pillar may state a higher maximum vehicle load capacity than the vehicle is designed for. As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification."

  If the load capacity information is incorrect on the label, the vehicle may be overloaded, increasing the risk of a crash.

  Remedy

  DVUSA will notify owners, and dealers will check the label and replace it if necessary, free of charge. The recall began on December 15, 2017. Owners may contact DVUSA customer service at 1-877-762-8267.

• NHTSA recall #17V592000September 22, 2017109 vehicles affected

  power train: driveline: driveshaft

  Daimler Vans USA, LLC (DVUSA) is recalling certain 2016 Mercedes-Benz Sprinter 2500/3500 vehicles. The affected vehicles were manufactured without a driveshaft catch strap, allowing a loose driveshaft to strike the fuel tank.

  A loose driveshaft may strike and puncture the gas tank, resulting in a fuel leak, increasing the risk of a fire.

  Remedy

  DVUSA will notify owners, and dealers will install the missing catch strap for the driveshaft, free of charge. Daimler issued an interim notification to owners on November 17, 2017. The recall began on December 21, 2017. Owners may contact DVUSA customer service at 1-877-762-8267.

• NHTSA recall #17V364000June 5, 20171,257 vehicles affected

  equipment: other: labels

  Daimler Vans USA, LLC (DVUSA) is recalling certain 2016 Mercedes-Benz and Freightliner Sprinter 2500 and 3500 vehicles equipped with reinforced front axles. The affected vehicles have tire labels on the B-pillar that list a tire pressure that is too low.

  Operating the vehicle with low front tire pressures may result in tire damage, increasing the risk of a crash.

  Remedy

  DVUSA will notify owners, Freightliner Sprinter and Mercedes-Benz dealers will check and replace the tire label, as necessary, free of charge. The recall began on August 5, 2017. Owners may contact DVUSA customer service at 1-877-762-8267.

• NHTSA recall #17V149000March 7, 2017892 vehicles affected

  power train: driveline: driveshaft

  Daimler Vans USA, LLC (DVUSA) is recalling certain 2016 Mercedes-Benz Sprinter 2500 and 3500 vehicles and Freightliner Sprinter 2500 and 3500 vehicles. The bracket for the center support bearing of the drive shaft may not have been properly welded.

  If the event of a crash, the bracket may detach and the drive shaft may damage the fuel system, increasing the risk of a fire.

  Remedy

  DVUSA will notify owners and dealers will install three additional rivets to secure the bracket, free of charge. Interim notices informing owners of the safety risk were mailed on May 5, 2017. The recall began on July 7, 2017. Owners may contact DVUSA customer service at 1-877-762-8267.

• NHTSA recall #17V093000February 10, 201715,338 vehicles affected

  air bags

  Daimler Vans USA, LLC (DVUSA) is recalling certain 2013-2016 Mercedes-Benz Sprinter 2500 and 3500 and Freightliner Sprinter 2500 and 3500 vans. These vehicles were manufactured without a reinforcement plate and protective bracket on the air bag control unit. As a result, the air bag control unit may not remain functional after the initial impact, possibly preventing additional air bags from deploying in response to a secondary impact.

  If additional air bags do not deploy as intended, the occupants are at an increased risk of injury.

  Remedy

  DVUSA will notify owners, and dealers will install a reinforcement plate and protective bracket around the air bag control unit, free of charge. The recall began on May 26, 2017. Owners may contact DVUSA customer service at 1-877-762-8267.

• NHTSA recall #16V853000November 28, 201628 vehicles affected

  seat belts: front: anchorage

  Midwest Automotive Designs, LLC (Midwest) is recalling certain model year 2016 Mercedes Benz Sprinter 2500 and 3500 vehicles manufactured July 1, 2016, to September 30, 2016, equipped with certain left side seat adjusters, model number 486077 manufactured by Atwood. The affected seat adjusters may allow the seats to move in the event of a crash. As such, these adjusters fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages", and 207 "Seating Systems."

  If the seat moves in the event of a crash, the seat occupant would be at an increased risk of injury.

  Remedy

  Midwest will notify owners, and dealers will replace the left slide track, free of charge. The recall began on December 22, 2016. Owners may contact Midwest customer service at 1-574-522-4878.

• NHTSA recall #16V670000September 15, 2016271 vehicles affected

  seat belts: rear/other

  Daimler Vans USA, LLC (DVUSA) is recalling certain model year 2016 Mercedes-Benz and Freightliner Sprinter 2500 and 3500 vehicles manufactured March 1, 2016, to May 31, 2016. The bolts connecting the lower seat belt connection to the rear bench seat may not have been properly tightened.

  If the bolts were not properly tightened, the seat belt may fail to secure the seat occupant in the event of a crash.

  Remedy

  DVUSA will notify owners, and Sprinter dealers will inspect the connecting bolts, tightening them as necessary, free of charge. The recall began on November 18, 2016. Owners may contact DVUSA customer service at 1-877-762-8267.

• NHTSA recall #16V351000May 24, 20163 vehicles affected

  structure: body: roof and pillars

  Daimler Vans USA, LLC (DVUSA) is recalling certain model year 2015-2016 Mercedes-Benz Sprinter 2500 and 3500 vehicles manufactured May 31, 2015, to April 30, 2016, and 2015-2016 Freightliner Sprinter 2500 and 3500 vehicles manufactured May 1, 2015, to April 30, 2016. The affected vehicles are configured to have super-high roofs, but may not be equipped with the required crash pads.

  If the required crash pads are missing, it can increase the risk of injury to a front passenger seat occupant if they are unbelted.

  Remedy

  DVUSA will notify owners, and dealers will install the required crash-pads, free of charge. The recall began on August 11, 2016. Owners may contact DVUSA customer service at 1-877-762-8267.

• NHTSA recall #16V261000April 29, 201655 vehicles affected

  structure: body

  Daimler Vans USA, LLC (DVUSA) is recalling certain model year 2015-2016 Mercedes Benz and Freightliner Sprinter 2500 and 3500 vehicles manufactured April 1, 2015, to October 31, 2015. The affected vehicles may have had multiple layers of paint applied, and as a result, in a crash, the windows may separate from the vehicle when the outer layer of paint peels from the layer below.

  If the windows separate from the vehicle in a crash, the occupants are at a greater risk of injury.

  Remedy

  DVUSA will notify owners, and dealers will remove the windows and inspect the paintwork, repainting the vehicles as necessary, free of charge. This recall began August 4, 2016. Owners may contact DVUSA customer service at 1-770-705-2070.

• NHTSA recall #16V093000February 18, 20162,278 vehicles affected

  equipment: other: labels

  Daimler Vans USA, LLC (DVUSA) is recalling certain model year 2015-2016 Mercedes-Benz and Freightliner Sprinter 2500 and 3500 vans manufactured April 29, 2015, to December 15, 2015. The affected vehicles have a tire pressure label that incorrectly states a higher maximum load capacity than the vehicle is designed for.

  The vehicle may be overloaded if loaded to the incorrect weight shown on the label, possibly resulting in axle or tire failure, increasing the risk of a crash.

  Remedy

  DVUSA will notify owners, and Mercedes-Benz and Freightliner dealers will replace the incorrect tire pressure label, free of charge. The recall began March 2016. Owners may contact DVUSA customer service at 1-877-762-8267.

Other model years

• 2013 27
• 2014 55
• 2016
• 2017 28
• 2019 27