2006 Lexus GS

Complaint history

When NHTSA received these reports. Changes in reporting alone do not establish a change in failure rates.

Problems owners report

Listed groups have at least 3 complaints. The page includes the 20 largest groups plus any additional flagged groups; some complaints are not assigned to a group.

AI groups complaints by meaning; the groups are approximate. Share ratio compares the problem’s share of this vehicle’s complaints with its share on other vehicles over the last 24 months (shown from 3 recent complaints). A 2× ratio means twice the complaint share, not twice the failure risk. Flags mark unusual shares or recent surges after an AI review of the complaint content. “First signal” does not mean the pattern has persisted continuously.How recall estimates are calculated.

Recalls

• NHTSA recall #11V029000January 26, 2011244,779 vehicles affected

  fuel system, gasoline: delivery

  Toyota is recalling certain model year 2006-2009 Lexus is and model year 2006-2007 Lexus gs vehicles. Due to insufficient tightening of the fuel pressure sensor connected to an engine fuel delivery pipe with nickel phosphorus plating, there is a possibility that, over time, the pressure sensor could loosen. If loosening occurs, fuel could leak past a gasket used in the connection between the sensor and the pipe and through the threaded portion of the sensor.

  Fuel leakage, in the presence of an ignition source, could result in a fire.

  Remedy

  Dealers will inspect for fuel leakage from the threaded portion of the fuel pressure sensor and if a fuel leak is not confirmed, dealers will further tighten the fuel pressure sensor with the proper torque. If a fuel leak is confirmed, the gasket between the sensor and the fuel deliver pipe will be replaced with a new one, and the sensor will be tightened with the proper torque. This service will be performed free of charge. The safety recall began on march 7, 2011. Owners may contact Toyota at 1-800-331-4331.

• NHTSA recall #10V499000October 21, 2010728,544 vehicles affected

  service brakes, hydraulic: foundation components: master cylinder

  Toyota is recalling certain model year 2005-2006 avalon, model year 2004-2006 highlander, model year 2004-2006 Lexus rx, and model year 2006 Lexus gs and is vehicles. Brake fluid containing polymers is used that acts as lubricants for certain brake system components. If replacement brake fluid is used that does not contain such polymers, or that contains only small amounts, a part of the rubber seal located at the rear of the brake master cylinder may become dry, and the seal may curl during movement of the piston. If this occurs, a small amount of brake fluid could slowly leak from the seal into the brake booster.

  A leak of brake fluid could lead to a change in brake pedal feel and overtime a degradation in braking performance increasing the risk of a crash.

  Remedy

  Dealers will replace the seal with a newly designed one. This service will be performed free of charge. The safety recall began on november 15, 2010. Owners may contact Toyota at 1-800-331-4331 and Lexus at 1-800-255-3987.

• NHTSA recall #09V020000January 16, 2009214,570 vehicles affected

  engine and engine cooling

  Toyota is recalling 214,570 my 2006-2008 Lexus is, my 2006-2007 gs and my 2007-2008 ls passenger vehicles equipped with aluminum fuel delivery pipes (fuel rails). Ethanol fuels with a low moisture content will corrode the internal surface of the fuel rails. As this condition progresses, the engine malfunction indicator light may illuminate.

  Over time, the corrosion may create a pinhole resulting in fuel leakage. Fuel leakage, in the presence of an ignition source, could result in a fire.

  Remedy

  Dealers will inspect and replace the fuel delivery pipes free of charge. The recall is expected to begin during february 2009. Owners may contact Toyota/Lexus at 1-800-255-3987.

• NHTSA recall #07V545000November 28, 200734,343 vehicles affected

  fuel system, gasoline: delivery: hoses, lines/piping, and fittings

  On certain vehicles, high stress areas may have been created in two specific fuel pipes located in the engine compartment. Combined with other factors such as the presence of corrosive agents in fuel, a crack may form over time leading to fuel leakage from the fuel line(s).

  Fuel leakage in the presence of an ignition source could result in a fire.

  Remedy

  Dealers will replace the two involved fuel lines with newly designed lines free of charge. The recall began on december 15, 2007. Owners may contact Lexus at 1-800-255-3987.

• NHTSA recall #06V121000April 13, 200628,947 vehicles affected

  seat belts: front

  On certain passenger vehicles, if the front seat belt retractors (both driver and front passenger) become locked, they may not release due to a component of the emergency locking system. If the seat belt is locked in this condition, the occupant may not be able to properly fasten the seat belt.

  An occupant not properly wearing a seat belt may have an increased risk of injury during a crash.

  Remedy

  Dealers will replace the front seat belt assemblies. The recall began on april 21, 2006. Owners may contact Lexus at 1-800-255-3987.

• NHTSA recall #06V096000April 3, 2006133 vehicles affected

  air bags

  On certain vehicles, due to improper assembly of the air bag inflator, which is used in the side air bag, the curtain shield air bag, and the knee air bag assembly, some inflators were produced with an insufficient amount of the heating agents necessary for proper air bag deployment. In this condition, the expansion force of the gas may be insufficient to properly inflate the air bag when the SRS system is activated during a crash.

  This may increase the risk of injury to the occupant in the involved seating position in the event of a crash.

  Remedy

  Dealers will replace the specific SRS air bag. The recall began on april 6, 2006. Owners may contact Toyota at 1-888-270-9371, Scion at 1-866-548-1851, or Lexus at 1-800-255-3987.

Other model years

• 2006
• 2007 25