2017 GMC Sierra 2500

Complaint history

When NHTSA received these reports. Changes in reporting alone do not establish a change in failure rates.

Problems owners report

Listed groups have at least 3 complaints. The page includes the 20 largest groups plus any additional flagged groups; some complaints are not assigned to a group.

AI groups complaints by meaning; the groups are approximate. Share ratio compares the problem’s share of this vehicle’s complaints with its share on other vehicles over the last 24 months (shown from 3 recent complaints). A 2× ratio means twice the complaint share, not twice the failure risk. Flags mark unusual shares or recent surges after an AI review of the complaint content. “First signal” does not mean the pattern has persisted continuously.How recall estimates are calculated.

Recalls

• NHTSA recall #23V047000February 2, 202322,132 vehicles affected

  fuel system, diesel: storage: tank assembly

  General Motors, LLC (GM) is recalling certain 2017-2019 Chevrolet Silverado 2500, 3500, and GMC Sierra 2500, 3500 vehicles equipped with a dual fuel tank option. The rear fuel tank may collapse and prevent the fuel pump from transferring fuel to the front tank, resulting in an engine stall.

  An engine stall increases the risk of a crash.

  Remedy

  Dealers will inspect the fuel tank and fuel pump module, replacing them as necessary. Dealers will also add a vent hose to the rear tank assembly. Repairs will be performed free of charge. An interim owner notification letter informing owners of the safety risk was mailed on March 15, 2023. Owner notification letters were mailed June 21, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is N222368030.

• NHTSA recall #21V496000July 1, 2021338,020 vehicles affected

  equipment: electrical: engine block heater

  General Motors, LLC (GM) is recalling certain 2017-2019 Chevrolet Silverado 2500, 3500 and 2017-2019 GMC Sierra 2500 and 3500 vehicles equipped with a Duramax diesel 6.6 liter engine and an optional engine-block heater cord. An electrical short-circuit may occur in the engine-block heater cable or in the terminals that connect the heater cable to the block heater.

  An electrical short-circuit can increase the risk of a fire.

  Remedy

  Dealers will replace engine block heaters and heater cords. Vehicles that have this feature disabled as a remedy to the safety condition will be contacted and offered replacement block heaters and heater cords under a separate customer satisfaction program, free of charge. GM will provide free replacement block heaters and cords under a separate customer satisfaction campaign. For vehicles previously included in recall 19V-328, the heater cord will be replaced and rerouted, free of charge. Interim owner notifications were mailed on August 13, 2021. Owner notification letters are expected to be mailed on April 4, 2022. Customers may call GMC customer service at 1-800-462-8782. GM's number for this recall is 212329840.

• NHTSA recall #19V328000April 25, 2019318,374 vehicles affected

  engine

  General Motors LLC (GM) is recalling certain 2019 Chevrolet Silverado 4500, 5500 and 6500 vehicles and 2017-2019 Chevrolet Silverado 2500 and 3500 vehicles and GMC Sierra 2500 and 3500 vehicles equipped with Duramax 6.6 liter diesel engines and an optional engine-block heater. The engine block heater cord or the terminals that connect the heater cord to the block heater may short circuit and fail.

  A short-circuit may damage the engine components and increase the risk of fire.

  Remedy

  GM will contact owners, dealers will replace the engine block heater, free of charge. Additionally, in Chevrolet Silverado 2500 and 3500 vehicles, dealers will install a new rerouted heater cord. The recall began December 11, 2019. Owners may contact GM customer service at 1-586-596-1733. GM's number for this recall is N182206310.

• NHTSA recall #17V567000September 14, 201738,048 vehicles affected

  seat belts: front: retractor

  General Motors (GM) is recalling certain 2017-2018 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 trucks. The front seat belt retractor assemblies were built with the incorrect torsion bar. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 209, "Seat Belt Assemblies."

  The seat belt retractors may not perform as intended during a crash, increasing the risk of injury.

  Remedy

  GM will notify owners, and dealers will replace both front seat belt retractor assemblies, free of charge. The recall began March 24, 2021. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. GM's numbers for this recall are 17368, 17375, and 17376.

• NHTSA recall #17V437000July 10, 201740,683 vehicles affected

  air bags: frontal; air bags: frontal: sensor/control module-inactive; seat belts: pretensioner

  General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.

  A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.

  Remedy

  GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.

• NHTSA recall #16V651000September 8, 20163,640,162 vehicles affected

  air bags: frontal; air bags: frontal: sensor/control module-inactive; seat belts: pretensioner

  General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.

  A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.

  Remedy

  GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.

Other model years

• 1999 36
• 2000 48
• 2001 134
• 2002 134
• 2003 160
• 2004 143
• 2005 115
• 2006 66
• 2007 83
• 2008 63
• 2009 31
• 2011 63
• 2012 31
• 2013 46
• 2014 30
• 2015 89
• 2016 59
• 2017
• 2018 35
• 2019 32
• 2020 79
• 2021 52
• 2022 45
• 2023 33
• 2024 107
• 2025 28