2003 GMC Envoy

Complaint history

When NHTSA received these reports. Changes in reporting alone do not establish a change in failure rates.

Problems owners report

Listed groups have at least 3 complaints. The page includes the 20 largest groups plus any additional flagged groups; some complaints are not assigned to a group.

AI groups complaints by meaning; the groups are approximate. Share ratio compares the problem’s share of this vehicle’s complaints with its share on other vehicles over the last 24 months (shown from 3 recent complaints). A 2× ratio means twice the complaint share, not twice the failure risk. Flags mark unusual shares or recent surges after an AI review of the complaint content. “First signal” does not mean the pattern has persisted continuously.How recall estimates are calculated.

Recalls

• NHTSA recall #05V198000May 5, 2005286,478 vehicles affected

  exterior lighting: turn signal

  On certain trucks and sport utility vehicles, the driver wishing to signal a turn by moving the directional signal lever, (up or down) may cause the front marker/turn lights and rear turn lights to flash in a manner similar to hazard warning, rather than flashing on the desired side only.

  The driver may not be able to clearly signal their intentions to turn, change travel lanes, or potentially warn others of an impaired vehicle operating condition increasing the risk of a crash.

  Remedy

  Dealers will replace the suspect flasher modules with a new flasher module designed with sealed relays and more durable contact material inside of the relays free of charge. The recall began on august 4, 2005. Isuzu began mailing owner letters on august 4, 2005. Owners may contact Chevrolet at 1-800-630-2438, Gmc at 1-866-996-9463, Isuzu at 1-800-255-6727, Buick at 1-866-608-8080, and Oldsmobile at 1-800-630-6537.

• NHTSA recall #04V046000February 4, 2004581,394 vehicles affected

  visibility: windshield wiper/washer

  Certain sport utility vehicles have windshield wiper systems that will not turn on, cease operation while in use, fail to turn off/on by themselves (moisture sensitive wiper system), or have continuous windshield washer pump operation because the presence of water within the wiper modules Can either cause a short circuit or Can lead to the corrosion of components within the module.

  Depending on the occurrence and weather situation, driver visibility could be reduced, which could result in a crash.

  Remedy

  Dealers will cover the windshield wiper module vent hole with a patch. Also, the wiper motor, circuit board, and electrical connector will be inspected to signs of water intrusion and/or corrosion and be replaced as required. The recall began july 6, 2004. Owners should contact Chevrolet at 1-800-630-2438; Oldsmobile at 1-800-630-6537; or Gmc at 1-866-996-9463.

• NHTSA recall #03V250000July 15, 20031,707,825 vehicles affected

  equipment: other: owners/service/other manual

  Certain minivans, passenger and sport utility vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 225, "child restraint anchorage system." the owner's manual does not explain the meaning of the location symbols for the child restraint lower universal anchorage system.

  This does not meet the requirements of the standard.

  Remedy

  Owners will be provided with a supplement for their owner's manual. This supplement describes and shows the location symbols for the child restraint anchors that are located in the vehicle and on the child restraint or booster cushion. Owner notification began august 18, 2003. Owners should contact Buick at 1-866-608-8080, Cadillac at 1-866-982-2339, Chevrolet at 1-800-630-2438, Gmc at 1-866-996-9463, Pontiac at 1-800-620-7668, or Oldsmobile at 1-800-630-6537.

• NHTSA recall #03V151000April 23, 200344,653 vehicles affected

  service brakes, hydraulic: foundation components: hoses, lines/piping, and fittings

  Certain sport utility vehicles were built with a left-front brake pipe with a circumferential score at a random location along the length of the pipe as the result of the manufacturing process. If the brake pipe partially or fully fractured, brake pedal travel would immediately increase and front brake performance would be reduced.

  If braking performance is reduced, a crash could occur.

  Remedy

  Dealers will replace the left-front brake pipe. Owner notification began on may 29, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact Chevrolet at 1-800-222-1020, Gmc at 1-800-462-8782, or Oldsmobile at 1-800-442-8006.

• NHTSA recall #03V075000March 6, 2003511,167 vehicles affected

  power train: automatic transmission

  Certain sport utility vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 114, "theft protection." these vehicles are equipped with a mechanical override that could allow the ignition key to be removed with the shift lever in a position other than park. In addition, these vehicles have an override that Can allow the transmission to be shifted out of park with the ignition in the off position.

  These overrides are not permitted unless the vehicle has a locking steering column.

  Remedy

  Dealers will eliminate these conditions by disabling the overrides. Owner notification began on may 29, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact Chevrolet at 1-800-222-1020, Gmc at 1-800-462-8782, Oldsmobile at 1-800-442-6537, or Hummer at 1-866-486-6376.

• NHTSA recall #03V051000February 14, 2003130 vehicles affected

  air bags: frontal: driver side: inflator module

  On certain mini vans, passenger and sport utility vehicles, some of these vehicles have a driver's side air bag that may not deploy as designed. In addition, the air bag inflator could rupture.

  This could result in reduced capability of the air bag to protect the driver. Also if the air bag inflator ruptured, pieces of the inflator could strike and injure the vehicle occupants.

  Remedy

  Dealers will inspect, and if necessary, install a new driver's air bag. Owner notification began on march 11, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact Buick at 1-800-521-7300, Cadillac at 1-800-458-8006, Chevrolet at 1-800-222-1020, Gmc at 1-800-462-8782, or Pontiac at 1-800-762-2737.

• NHTSA recall #02V222000August 9, 2002133,221 vehicles affected

  air bags: frontal

  Certain passenger, mini vans, and sport utility vehicles have an air bag inflator on the driver's side that could fracture at a weld during a deployment.

  Pieces of the inflator could strike and injure vehicle occupants and the air bag cushion would not inflate fully, reducing the capability of the bag to protect the driver.

  Remedy

  Dealers will inspect, and replace, if necessary, the air bag module assembly on the driver's side. Owner notification began august 15, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact Buick at 1-800-521-7300, Cadillac at 1-800-458-8006, Chevrolet at 1-800-222-1020, Gmc at 1-800-462-8782, Oldsmobile at 1-800-442-6537, or Pontiac at 1-800-762-2737.

Other model years

• 2002 487
• 2003
• 2004 367
• 2005 488
• 2006 352
• 2007 219
• 2008 77