2019 Chrysler Pacifica Plug-IN Hybrid

Complaint history

When NHTSA received these reports. Changes in reporting alone do not establish a change in failure rates.

Problems owners report

Listed groups have at least 3 complaints. The page includes the 20 largest groups plus any additional flagged groups; some complaints are not assigned to a group.

AI groups complaints by meaning; the groups are approximate. Share ratio compares the problem’s share of this vehicle’s complaints with its share on other vehicles over the last 24 months (shown from 3 recent complaints). A 2× ratio means twice the complaint share, not twice the failure risk. Flags mark unusual shares or recent surges after an AI review of the complaint content. “First signal” does not mean the pattern has persisted continuously.How recall estimates are calculated.

Recalls

• NHTSA recall #24V538000July 18, 20243,606 vehicles affected

  Park outside: NHTSA advises this until the repair is done.

  hybrid propulsion system

  Chrysler (FCA US, LLC) is recalling certain 2019-2021 Pacifica Plug-In Hybrid Electric (PHEV) vehicles. The battery pack may cause a vehicle fire when parked, even with the ignition in the "Off" position.

  A vehicle fire increases the risk of injury.

  Remedy

  Owners are advised not to charge their vehicles, and to park outside and away from structures, until they are repaired. Dealers will update the high voltage battery pack control module (BPCM) software. In addition, dealers will inspect and if necessary, replace the battery pack assembly. Repairs will be performed free of charge. Owner notification letters were mailed March 6, 2025. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is 72B. This recall is an expansion of NHTSA recall number 22V-077.

• NHTSA recall #20V334000June 9, 202023,079 vehicles affected

  electrical system: 12v/24v/48v battery: cables; electrical system: wiring: interior/under dash

  Chrysler (FCA US LLC) is recalling certain 2017-2020 Pacifica Plug-in Hybrid Electric Vehicles ("PHEV"). The 12 volt isolator post located behind the driver's seat may develop high resistance.

  A high resistance electrical connection may result in the connection overheating, increasing the risk of a fire with the vehicle on or off.

  Remedy

  FCA will conduct a voluntary safety recall on affected vehicles to increase the torque and install a waterproof gasket to the 12v isolator post, the post will also be inspected for signs of contamination. In the event the post is compromised, the 12v isolator post and associated cables will be replaced. Until the final remedy is available, customers should bring their vehicles to dealers for an interim inspection of this joint. The recall remedy is currently under development. FCA US LLC will notify owners, and dealers will perform an interim inspection of this joint. If the inspection indicates the joint is compromised, owners will receive a loaner vehicle, until a final remedy is developed. Interim notifications are expected to begin around June 22, 2020. The recall began July 30, 2020. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is W46. Note: Consumers are advised to exercise the following precautions until the vehicle has the final repair completed: do not park these vehicles inside of buildings or structures, or near other vehicles. Additionally, keep liquids out of the backseat area, including but not limited to beverages, wet items, umbrellas, or bottled liquids that may leak.

Other model years

• 2017 79
• 2018 224
• 2019
• 2020 58
• 2021 26
• 2022 116
• 2023 40
• 2024 26