2004 Volkswagen Beetle

Complaint history

When NHTSA received these reports. Changes in reporting alone do not establish a change in failure rates.

Problems owners report

Listed groups have at least 3 complaints. The page includes the 20 largest groups plus any additional flagged groups; some complaints are not assigned to a group.

AI groups complaints by meaning; the groups are approximate. Share ratio compares the problem’s share of this vehicle’s complaints with its share on other vehicles over the last 24 months (shown from 3 recent complaints). A 2× ratio means twice the complaint share, not twice the failure risk. Flags mark unusual shares or recent surges after an AI review of the complaint content. “First signal” does not mean the pattern has persisted continuously.How recall estimates are calculated.

Recalls

• NHTSA recall #08V178000April 17, 200876,900 vehicles affected

  air bags: frontal: sensor/control module-inactive

  Volkswagen is recalling 76,900 my 2004-2005 new Beetle and my 2003-2005 new Beetle convertibles equipped with an advanced (dual-stage) air bag system. This system may have air bag frontal crash sensors that contain a solder joint on the circuit board that may crack under certain high temperature conditions. If this occurs, the air bag indicator light will illuminate and the fallback algorithm will ensure that the front air bags always deploy in a frontal crash in which the vehicle's deceleration is high enough to activate the frontal air bags.

  In low-severity frontal impacts, the front air bags may deploy more forcefully than designed, increasing the possibility of injury to out-of-position front seat occupants.

  Remedy

  Dealers will inspect each vehicle to determine that the specific defect crash sensor is present on one or both sides of the vehicle. All of the defect crash sensors will be replaced free of charge. The recall is expected to begin on or before july 31, 2008. Owners may contact Volkswagen at 1-800-822-8987.

• NHTSA recall #07V063000February 20, 20071,002,000 vehicles affected

  exterior lighting: brake lights: switch

  On certain passenger, wagon, and convertible vehicles equipped with or without cruise control, a brake light switch may malfunction if it was installed incorrectly.

  The brake lights could become inoperative, or remain on. Failure to provide the proper signal when braking could lead to a crash without warning.

  Remedy

  Dealers will install the newly designed brake light switch free of charge. The recall began on april 27, 2007, and will be conducted in several staggered mailings through september 21, 2007. Vehicles within the make, model, and model year of this population may be involved in either this recall or 06V-183, but not both. The remedy is the same for each recall. Volkswagen dealers will apply the remedy based on the VIN number of the vehicle. Owners may contact vw at 1-800-822-8987.

• NHTSA recall #04V586000December 15, 200419,284 vehicles affected

  fuel system, diesel

  On certain passenger vehicles, the high pressure diesel pumps were produced with an improper fastener, which could allow diesel fuel to escape from the pump.

  Fuel leakage in the presence of an ignition source may lead to a fire.

  Remedy

  Dealers will replace the diesel pump. The recall began on february 8, 2005. Owners should contact Volkswagen at 1-800-822-8987.

Other model years

• 1998 171
• 1999 174
• 2000 263
• 2001 203
• 2002 165
• 2003 314
• 2004
• 2005 261
• 2006 124
• 2007 56
• 2008 60
• 2009 33
• 2010 30
• 2012 65
• 2013 93
• 2014 50
• 2015 83
• 2016 48