2005 Toyota Sienna

Complaint history

When NHTSA received these reports. Changes in reporting alone do not establish a change in failure rates.

Problems owners report

Listed groups have at least 3 complaints. The page includes the 20 largest groups plus any additional flagged groups; some complaints are not assigned to a group.

AI groups complaints by meaning; the groups are approximate. Share ratio compares the problem’s share of this vehicle’s complaints with its share on other vehicles over the last 24 months (shown from 3 recent complaints). A 2× ratio means twice the complaint share, not twice the failure risk. Flags mark unusual shares or recent surges after an AI review of the complaint content. “First signal” does not mean the pattern has persisted continuously.How recall estimates are calculated.

Recalls

• NHTSA recall #17V657000October 18, 2017310,475 vehicles affected

  power train: automatic transmission

  Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2005-2007 and 2009-2010 Toyota Sienna vehicles. In the affected vehicles, due to a problem within the shift lock assembly, the shift lever may be moved out of the 'Park' position without depressing the brake pedal.

  If the shift lever can be moved from the "Park" position without depressing the brake pedal and the parking brake is not applied, the vehicle may roll, increasing the risk of a crash.

  Remedy

  Toyota will notify owners, and dealers will replace the shift lock solenoid and reapply the grease, free of charge. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is H0V. Vehicles that were previously recalled under campaign 13V-429 are not affected by this recall.

• NHTSA recall #16V396000June 2, 20167,749 vehicles affected

  seats: front assembly: seat heater/cooler

  Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.

  If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.

  Remedy

  SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.

• NHTSA recall #14V743000November 19, 20143,233 vehicles affected

  seats: front assembly: seat heater/cooler

  Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.

  Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.

  Remedy

  SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.

• NHTSA recall #14V273000May 22, 2014419,520 vehicles affected

  tires: temporary/emergency spare tire

  Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2004-2011 Sienna vehicles originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin and the District of Columbia. The affected vehicles have a spare tire carrier assembly mounted under the vehicle whose attachment cable may corrode due to high concentrations of road salt splashing onto the spare tire carrier.

  If the carrier cable is corroded due to road salt, the spare tire may separate from the vehicle, increasing the risk of a crash.

  Remedy

  Toyota sent owners in August 2014 an interim notification to advise owners of the recall and that dealers will perform an interim remedy to remove the spare tire and relocate it to the luggage compartment, free of charge. Owners are being mailed a second letter as parts become available and dealers will replace the spare tire carrier assembly with an improved one, free of charge. The remedy campaign is being performed in phases. The first phase of the recall began July 7, 2015. Owners may contact Toyota customer service at 1-800-331-4331. NOTE: 2004-2010 Siennas subject to this recall were subject to recall campaign 10V-160 initiated in 2010. Those owners are advised that they must have their vehicles remedied again under this campaign and that having the earlier recall completed did not remedy their vehicles. Additionally, model year 1998-2003 Siennas were recalled as part of safety recall 10V-160. Owners of those vehicles that have not had not the remedy performed on their vehicles, should contact their Toyota dealer to schedule a free repair.

• NHTSA recall #13V429000September 26, 2013614,722 vehicles affected

  power train: automatic transmission

  Toyota is recalling certain model year 2004-2005 Sienna vehicles manufactured January 10, 2003, through August 10, 2005; and model year 2007-2009 Sienna vehicles manufactured February 20, 2007, through December 12, 2008. In the affected vehicles, due to a problem within the shift lock solenoid, there is a possibility that the shift lever could be moved out of Park position without depressing the brake pedal.

  If the shift lever is moved out of the Park position without the brake applied, the transmission will either engage a drive gear or Neutral, increasing the risk of a backover or roll away crash.

  Remedy

  Toyota will mail interim notifications to owners beginning in late October 2013. When parts are available, owners will be sent a second notice and dealers will replace the shift lock solenoid, free of charge. Owners may contact Toyota at 1-800-331-4331.

• NHTSA recall #11V539000November 9, 2011420,326 vehicles affected

  engine and engine cooling

  Toyota is recalling certain model year 2004 avalon vehicles; 2004 and 2005 camry, camry solara, highlander, and Sienna vehicles, 2006 highlander hybrid; 2004 and 2005 Lexus ES330 and RX330; and 2006 Lexus RX400H vehicles manufactured from june 1, 2004 through march 31, 2005, equipped with the 1MZ-FE or 3MZ-FE engine. The amount of adhesive agent applied between the outer ring and the torsional rubber damper (inner ring) in the crankshaft pulley may be inadequate. If the adhesive is insufficient, there is a possibility that the outer ring may become misaligned and it may not properly rotate with the inner ring, causing noise and/or illumination of the battery discharge indicator light.

  In some cases, the belt for the power steering pump may become detached from the pulley which could result in a loss of power steering and a sudden increase in steering effort, increasing the risk of a crash.

  Remedy

  Toyota will notify owners, and dealers will check the crankshaft pulley to identify whether it was produced by the U.S. Supplier. If so, the dealer will replace the pulley with a new one at no charge. The safety recall is expected to begin during early january 2012. Owners may contact Toyota at 1-800-331-4331.

• NHTSA recall #10V160000April 20, 2010600,000 vehicles affected

  structure

  Toyota is recalling certain model year 1998 through 2010 Sienna passenger vehicles manufactured between august 7, 1997 and january 4, 2010, currently registered in or originally sold in connecticut, delaware, illinois, indiana, kentucky, maine, maryland, massachusetts, michigan, minnesota, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, washington district of columbia, virginia, west virginia, and wisconsin. The subject vehicles are equipped with the spare tire stowed under the vehicle. If the vehicle is operated in the cold climate regions of the united states where road salt is frequently used, water splashed backwards with high concentrations of road salt Can reach the spare tire carrier and corrode the spare tire carrier assembly cable.

  The cable may break due to excessive corrosion and the spare tire may separate from the vehicle, possibly resulting in a vehicle crash.

  Remedy

  Toyota will notify owners with an interim letter initially instructing them to bring their vehicle to authorized dealers to inspect for corrosion. A second notice will be sent when the permanent remedy is available. For more information, please see toyota's amended recall report of july 19, 2010. The safety recall is expected to begin on october 12, 2010. Owners may contact Toyota at 1-800-331-4331.

• NHTSA recall #10V035000February 3, 2010271,417 vehicles affected

  equipment: other: labels

  Gulf states Toyota is recalling certain model year 2005-2010 vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims." these vehicles were sold between september 1, 2005 and june 2, 2008 without the requisite load carrying capacity modification labels.

  This does not meet the standard requirements.

  Remedy

  Dealers will mail to consumers the corrected label or the customer will have the option for dealers to install the label free of charge. Dealers will also correct the owner's manual. The safety recall began on may 27, 2010. Owners may contact gulf states Toyota at 713-580-3300.

• NHTSA recall #10V036000February 3, 2010153,418 vehicles affected

  equipment: other: labels

  Southeast Toyota is recalling certain model year 2005-2011 passenger vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims." these vehicles were sold without the requisite load carrying capacity modification labels.

  A driver may overload a vehicle which may increase the risk of a crash.

  Remedy

  Dealers will mail to consumers the corrected label or the customer will have the option for dealers to install the label free of charge. The safety recall began on may 27, 2010. Owners may contact southeast Toyota at 1-800-301-6859.

• NHTSA recall #09V234000June 25, 20092,204 vehicles affected

  equipment: other: labels

  Toyota is recalling certain model year 2006 through 2009 Sienna and 2009 Lexus gx passenger vehicles. The vehicle capacity weight on the tire and loading information label and the gvwr on the certification label is insufficient for certain vehicles. Some vehicles were accessorized through vehicle processing centers and had accessories installed that caused the vehicle to exceed the gvwr value. These vehicles fail to comply with the requirements of federal motor vehicle safety standard no 110, "tire selection and rims," and 49 cfr part 567.

  The gvwr is insufficient for the load carrying capacity of the vehicles.

  Remedy

  Toyota will notify owners instructing them to return their vehicle to a Toyota or Lexus dealer for an exchange of the certification label and the tire and loading information label, an installation of the load carrying capacity modification label, if necessary, and a correction to the owner's manual. This remedy will be performed free of charge. The safety recall began on december 10, 2009. Owners may contact Toyota at 1-888-270-9371.

• NHTSA recall #08V244000June 3, 2008196,222 vehicles affected

  structure: body: hatchback/liftgate

  Toyota is conducting a safety improvement campaign involving 196,222 my 2004-2006 Toyota Sienna vehicles equipped with power rear liftgate struts. The gas struts used to help lift and support the rear power liftgate could wear out sooner than expected. As the gas struts deteriorate, the performance of the liftgate will begin to degrade and the power rear liftgate will operate more slowly than when the gas struts were new.

  If not repaired, the gas struts may not be able to support the weight of the liftgate when it is open eventually, the gas struts could deteriorate to the point that the liftgate will fall about ten inches after it reaches the fully open position, at which point the power motor will engage and power the liftgate to the fully closed position. This condition may cause injury to a person who is struck by the liftgate when it falls or when it is closing.

  Remedy

  Dealers will replace the gas struts with newly designed gas struts that have a longer service life. The campaign began on august 8, 2008, and will be mailed in three phases ending in late december 2008. Owners may contact Toyota at 1-888-270-9371.

• NHTSA recall #05V327000July 20, 2005345,443 vehicles affected

  seat belts

  On certain mini vans, in the middle row seating position, the shoulder portion of the seat belt may bind in the bezel trim piece. The affected seat belt bezel is located on the shoulder portion of the seat in the right side seat of the seven passenger models and the center seating position in the eight passenger models.

  If the seat belt binds in the bezel, that extra webbing may exist in the seat belt which could result in an improperly fitted seat belt on a passenger. In the event of a crash, a seat occupant may not be properly restrained increasing the risk of personal injury.

  Remedy

  Dealers will replace the seat belt bezel and clip. The recall began august 5, 2005. Owners may contact Toyota at 1-800-331-4331.

Other model years

• 1998 294
• 1999 215
• 2000 363
• 2001 180
• 2002 181
• 2003 105
• 2004 2,062
• 2005
• 2006 1,017
• 2007 364
• 2008 429
• 2009 207
• 2010 172
• 2011 615
• 2012 247
• 2013 183
• 2014 163
• 2015 233
• 2016 76
• 2017 157
• 2018 72
• 2019 45
• 2020 38