2016 Mitsubishi Outlander

Complaint history

When NHTSA received these reports. Changes in reporting alone do not establish a change in failure rates.

Problems owners report

Listed groups have at least 3 complaints. The page includes the 20 largest groups plus any additional flagged groups; some complaints are not assigned to a group.

AI groups complaints by meaning; the groups are approximate. Share ratio compares the problem’s share of this vehicle’s complaints with its share on other vehicles over the last 24 months (shown from 3 recent complaints). A 2× ratio means twice the complaint share, not twice the failure risk. Flags mark unusual shares or recent surges after an AI review of the complaint content. “First signal” does not mean the pattern has persisted continuously.How recall estimates are calculated.

Recalls

• NHTSA recall #26V252000April 20, 2026108,046 vehicles affected

  structure: body: hatchback/liftgate: support device/strut

  Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2018-2022 Outlander PHEV and 2014-2020 Outlander vehicles. The liftgate gas spring cylinders may corrode and lose pressure, which can result in a gas spring cylinder rupture or the liftgate falling unexpectedly.

  A gas spring cylinder rupture or a liftgate falling unexpectedly can increase the risk of injury.

  Remedy

  MMNA will replace the left and right liftgate gas springs, free of charge. Owner notification letters were mailed June 17, 2026. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-26-001. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov June 3, 2026. This recall expands previous NHTSA recall number 25V507.

• NHTSA recall #25V507000August 7, 2025121,529 vehicles affected

  structure: body: hatchback/liftgate: support device/strut

  Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2018-2022 Outlander PHEV and 2014-2020 Outlander vehicles sold and/or currently registered in Alaska, Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kansas, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, North Dakota, Nebraska, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, South Dakota, Utah, Vermont, West Virginia, and Wisconsin. The liftgate gas spring cylinders may corrode and lose pressure, which can result in a gas spring cylinder rupture or the liftgate falling unexpectedly.

  A gas spring cylinder rupture or a liftgate falling unexpectedly can increase the risk of injury.

  Remedy

  MMNA will replace the left and right liftgate gas springs, free of charge. Owner notification letters were mailed October 6, 2025. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-25-002

• NHTSA recall #20V741000November 30, 202021,758 vehicles affected

  parking brake

  Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2016 Outlander and Outlander Sport vehicles. The rust prevention coating on the rear brake operating shafts could have been peeled off during the assembly process. As a result, water entering the rear brake caliper boot may cause the parking brake operating shafts to corrode and possibly bind.

  If the parking brake operating shafts bind, the parking brakes may not engage or disengage fully. If the parking brakes do not engage properly, the vehicle could rollaway, increasing the risk of a crash.

  Remedy

  MMNA will notify owners, and dealers will replace the rear brake caliper assemblies, free of charge. Owner letters were mailed May 4, 2021. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-20-005.

• NHTSA recall #20V403000July 13, 2020177,000 vehicles affected

  seat belts: rear/other: buckle assembly

  Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2014-2019 Outlander and 2018-2019 Outlander PHEV vehicles. The second-row center seat belt buckle may interfere with the right-side seat belt buckle when the seat backs are folded down. The interference may cause the right-side seat belt buckle cover to come off, making the buckle latch inoperable and unable to restrain an occupant.

  An unrestrained occupant has an increased risk of injury in the event of a crash.

  Remedy

  MMNA will notify owners, and dealers will modify the second-row center seat belt buckle cover, install a new warning label to the second-row seat support base, and provide a new warning label insert for the owner's manual, free of charge. The recall began September 1, 2020. Owners may contact MMNA customer service at 1-888-648-7820. Mitsubishi's number for this recall is SR-20-004.

• NHTSA recall #18V070000January 26, 2018170,354 vehicles affected

  parking brake

  Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2014-2016 Outlander and 2013-2016 Outlander Sport vehicles. Water may enter the rear brake calipers causing the parking brake actuator shafts to corrode and possibly bind.

  If the parking brake actuator shaft binds, the parking brake may not engage or disengage fully. If the parking brake does not engage properly, the vehicle may move unexpectedly if it is parked on a slope, increasing the risk of a crash.

  Remedy

  MMNA will notify owners, and dealers will inspect the rear brake calipers and replace the parking brake boot and lever or the brake caliper body, as necessary. Dealers will also replace the piston assembly of the rear brake caliper. These repairs will be performed free of charge. The recall is expected to begin March 27, 2018. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-18-002.

• NHTSA recall #17V609000September 29, 2017132,552 vehicles affected

  electrical system: starter assembly: relay

  Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2015-2017 Outlander, 2015-2016 Lancer and Outlander Sport, and 2015 Lancer Evolution vehicles. These vehicles may have defective relays that can result in an engine stall, reduced engine power or the engine overheating.

  If the engine stalls, there is an increased the risk of a crash.

  Remedy

  MMNA will notify owners, and dealers will replace the affected relays, free of charge. The recall began October 24, 2017. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-17-005.

• NHTSA recall #17V233000April 6, 201735,674 vehicles affected

  latches/locks/linkages: doors: latch

  Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2016 Outlander and Outlander Sport vehicles. The inside door latch mechanisms may not latch securely in high temperatures, allowing the doors to open while vehicle is in motion.

  If a door opens while the vehicle is being driven, it can increase the risk of injury.

  Remedy

  MMNA will notify owners, and dealers will replace the door latches, free of charge. The recall began August 25, 2017. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-17-002.

• NHTSA recall #16V563000July 28, 201682,436 vehicles affected

  power train: automatic transmission; power train: automatic transmission: control module (tcm/pcm/tecm)

  Mitsubishi Motors North America, Inc. (MMNA) is recalling certain model year 2015-2016 Outlander Sport vehicles and 2016 Outlander and Lancer vehicles. The affected vehicles are equipped with a constant velocity transmission (CVT) that, in certain driving conditions, may cause a delay in the vehicle accelerating.

  A hesitation during acceleration can increase the risk of a crash.

  Remedy

  MMNA has notified owners, and dealers will reprogram the CVT control unit with modified software, free of charge. The recall began on August 15, 2016. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-16-006.

Other model years

• 2003 116
• 2004 52
• 2007 125
• 2008 58
• 2009 46
• 2010 60
• 2011 58
• 2013 26
• 2014 45
• 2015 53
• 2016
• 2017 51
• 2018 57
• 2019 29
• 2020 32
• 2022 217
• 2023 50
• 2024 26