2006 GMC Envoy XL

Complaint history

When NHTSA received these reports. Changes in reporting alone do not establish a change in failure rates.

Problems owners report

Listed groups have at least 3 complaints. The page includes the 20 largest groups plus any additional flagged groups; some complaints are not assigned to a group.

AI groups complaints by meaning; the groups are approximate. Share ratio compares the problem’s share of this vehicle’s complaints with its share on other vehicles over the last 24 months (shown from 3 recent complaints). A 2× ratio means twice the complaint share, not twice the failure risk. Flags mark unusual shares or recent surges after an AI review of the complaint content. “First signal” does not mean the pattern has persisted continuously.How recall estimates are calculated.

Recalls

• NHTSA recall #15V599000September 24, 20159,932 vehicles affected

  visibility: power window devices and controls

  General Motors LLC (GM) is recalling certain model year 2006-2007 Buick Rainier, Chevrolet Trailblazer and GMC Envoy vehicles, and 2006 GMC Envoy XL and Chevrolet Trailblazer EXT vehicles. Fluid may enter into the driver's door master power window switch module, causing corrosion that could result in a short in the circuit board, causing window switches to become inoperative. Previously, the affected vehicles may have had their master power window switch module treated with a protective coating, instead of having it replaced.

  The protective coating may not eliminate the risk that the circuit board could short and result in a fire, even while the vehicle is unattended.

  Remedy

  GM will notify owners, and dealers will install a new driver's door switch module, free of charge. The recall began on November 2, 2015. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is 15700.

• NHTSA recall #15V519000August 14, 2015429,170 vehicles affected

  exterior lighting: headlights

  General Motors LLC (GM) is recalling certain model year 2007 Pontiac Grand Prix, 2006-2009 Buick LaCrosse, 2006-2007 Buick Rainier, Chevrolet Trailblazer, GMC Envoy, 2006 Chevrolet Trailblazer EXT, GMC Envoy XL, 2006-2008 Isuzu Ascender, and Saab 9-7x vehicles. In the affected vehicles, the headlamp driver module (HDM) may overheat and fail, causing the headlamps and daytime running lights to not illuminate.

  Headlamps that do not illuminate reduce the driver's ability to see the roadway and reduce the vehicle's visibility to oncoming vehicles, both of which increase the risk of a vehicle crash.

  Remedy

  GM will notify owners, and dealers will replace the HDM, free of charge. The recall began on May 17, 2016. Owners may contact Buick customer service at 1-800-521-7300 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14291.

• NHTSA recall #14V404000July 2, 2014184,611 vehicles affected

  visibility: power window devices and controls

  General Motors LLC (GM) is recalling certain model year 2005-2007 SAAB 9-7x; 2006 Chevrolet Trailblazer EXT and GMC Envoy XL; and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier and Isuzu Ascender vehicles. Fluid may enter the driver's door master power window switch module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.

  A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.

  Remedy

  GM will notify owners, and dealers will inspect the part number on the door module, and install a new door module if necessary, free of charge. Parts for the remedy are not currently available. An interim letter was mailed to owners in August 2014. A second owner letter will be mailed when parts are available. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-222-1020 (Chevrolet), 1-800-462-8782 (GMC), 1-800-955-9007 (SAAB), and 1-800-255-6727 (Isuzu). GM's number for this recall is 14309. NOTE: This recall provides a new remedy for all vehicles covered by recall 13V-248. Vehicles whose modules were modified but not replaced as part of the previous recall remedy must have their vehicles remedied again under this campaign.

• NHTSA recall #13V248000June 13, 2013193,652 vehicles affected

  electrical system; visibility: power window devices and controls

  General Motors (GM) is recalling certain model year 2005-2007 SAAB 9-7x; 2006 Chevrolet Trailblazer EXT and GMC Envoy XL; and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier and Isuzu Ascender vehicles. Fluid may enter the driver's door module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.

  A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.

  Remedy

  Owners will be contacted and dealers will test the driver's door module. If the module is functioning properly, a protective coating will be applied. If the module is not functioning properly, it will be replaced. These repairs will be done free of charge. GM will notify Buick, Chevrolet, and GMC owners, Isuzu and Saab will contact their respective owners. The recall began on August 2, 2013. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, GMC owners at 1-866-996-9463, Isuzu owners at 1-800-255-6727, and Saab owners at 1-800-955-9007. GM's campaign number is 12180. This recall is an expansion of recall 12V-406.

• NHTSA recall #05V455000October 5, 2005123,592 vehicles affected

  steering: hydraulic power assist: hose, piping, and connections

  Certain passenger vehicles may have been built with a power steering hose that is not to specification. Under extreme steering maneuvers, such as turning the steering wheel fully to the left or right while braking, the hose may fracture and leak fluid.

  If this were to occur, power steering assist would be lost and increased steering effort would be required. On vehicles equipped with hydro-boost power brakes, it could also result in loss of power brake assist and increased braking effort would be required. If the power steering fluid spray were to spray onto hot engine parts, an engine compartment fire could occur.

  Remedy

  Dealers will inspect the power steering hose(s) for two suspect date codes and replace them if required. The recall will begin on october 14, 2005. Owners may contact Chevrolet at 1-800-630-2438, Gmc at 1-866-996-9463, Buick at 1-866-608-8080, Cadillac at 1-866-982-2339, Isuzu at 1-800-255-6727, or Hummer at 1-800-732-5493.

Other model years

• 2002 70
• 2003 228
• 2004 187
• 2006