2008 Ford F-550 SD

Complaint history

When NHTSA received these reports. Changes in reporting alone do not establish a change in failure rates.

Problems owners report

Listed groups have at least 3 complaints. The page includes the 20 largest groups plus any additional flagged groups; some complaints are not assigned to a group.

AI groups complaints by meaning; the groups are approximate. Share ratio compares the problem’s share of this vehicle’s complaints with its share on other vehicles over the last 24 months (shown from 3 recent complaints). A 2× ratio means twice the complaint share, not twice the failure risk. Flags mark unusual shares or recent surges after an AI review of the complaint content. “First signal” does not mean the pattern has persisted continuously.How recall estimates are calculated.

Recalls

• NHTSA recall #09V456000November 19, 2009269 vehicles affected

  equipment: appliance: air conditioner

  Cues, inc. Is recalling certain model year 2007-2009 service vehicles built on various chassis equipped with carrier airv ceiling units, model nos. 68RV0010BA, 68RV0012CA, and 68RV0010EA. The heater element in these assemblies may be defective which could cause the unit to create smoke or sparks.

  This defect could result in a fire.

  Remedy

  Cues is working with carrier to remedy the affected vehicles. Repairs will be made by carrier free of charge. Please see carrier's defect report 09E-053. The safety recall began on january 5, 2010. Owners may contact carrier at 1-877-584-7059 or cues at 1-407-849-0190.

• NHTSA recall #08V096000February 28, 200887,515 vehicles affected

  seats

  Ford is recalling 87,515 my 2008 F250, F-350, F-450, and F-550 vehicles for failing to comply with all the requirements of federal motor vehicle safety standard no. 207, "seating systems." some 40% split and captain's chair driver's seats, equipped with lumbar supports, may have improper welds at the joint of the seat back pivot bracket and the seat back frame.

  In the event of a crash, the seat side pivot bracket may crack or break, increasing the risk of injury to the seat occupant.

  Remedy

  Dealers will add a reinforcement to the driver's seat back frame on the 40% split or captain's chair seat equipped with lumbar support or, if necessary, the seat back frame will be replaced. The recall began on march 28, 2008. Owners may contact Ford at 1-800-392-3673.

• NHTSA recall #07V139000March 26, 200733,169 vehicles affected

  power train: automatic transmission: control module (tcm/pcm/tecm)

  On certain trucks equipped with a 6.4L diesel engine, excessive temperatures in the diesel particulate filter in the exhaust system may result from excess hydrocarbons in the exhaust.

  Lack of power or rough operation, unusual noises from the engine or exhaust, white smoke from the exhaust, and potentially a visible flame out the tailpipe Can occur.

  Remedy

  Dealers will reprogram the power train control module. The recall began on april 3, 2007. Owners may contact Ford at 1-800-392-3673.

• NHTSA recall #07V140000March 26, 20071,022 vehicles affected

  electrical system: 12v/24v/48v battery

  On certain trucks equipped with a 6.4L diesel engine, insufficient clearance of the battery positive (b+) wire to the right hand splash shield bolt may result in the battery b+ wire contacting the splash shield bolt.

  Long term contact could cause wire chafe, resulting in copper wire being exposed. If this condition occurs, the battery b+ wire could short to ground increasing the risk of a fire.

  Remedy

  Dealers will inspect the battery b+ wire location and, if necessary, reposition the wire. The recall began on april 3, 2007. Owners may contact Ford at 1-800-392-3673.

Other model years

• 1999 61
• 2000 72
• 2001 29
• 2003 33
• 2004 49
• 2005 32
• 2006 44
• 2008