2017 Ford F-250 SD

Complaint history

When NHTSA received these reports. Changes in reporting alone do not establish a change in failure rates.

Problems owners report

Listed groups have at least 3 complaints. The page includes the 20 largest groups plus any additional flagged groups; some complaints are not assigned to a group.

AI groups complaints by meaning; the groups are approximate. Share ratio compares the problem’s share of this vehicle’s complaints with its share on other vehicles over the last 24 months (shown from 3 recent complaints). A 2× ratio means twice the complaint share, not twice the failure risk. Flags mark unusual shares or recent surges after an AI review of the complaint content. “First signal” does not mean the pattern has persisted continuously.How recall estimates are calculated.

Recalls

• NHTSA recall #25V572000September 3, 20251,456,417 vehicles affected

  back over prevention: sensing system: camera

  Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distorted, inverted, or blank image when the vehicle is in reverse.

  A rearview camera that displays an inverted, distorted, or blank image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.

  Remedy

  Dealers will inspect and replace the rearview camera as necessary, free of charge. Owner notification letters were mailed January 13, 2026. Ford owners will receive letters in phases, beginning January 2026 and June 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S89. This recall expands previous NHTSA recall number 25V270. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 8, 2025.

• NHTSA recall #22V880000November 29, 202218,808 vehicles affected

  power train: driveline: driveshaft

  Ford Motor Company (Ford) is recalling certain 2017-2018 F-Super Duty F-250, F-350, and F-450 4x4 vehicles. A radial damper inside the driveshaft may move out of position over time, which can cause a driveshaft imbalance and result in a fracture.

  A fractured driveshaft can cause a loss of drive power. Additionally, a vehicle rollaway could occur while parked if the parking brake is not engaged. Either of these scenarios increases the risk of a crash.

  Remedy

  Dealers will replace the driveshaft, free of charge. Owner notification letters were mailed July 27, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S74.

• NHTSA recall #22V644000August 26, 2022277,040 vehicles affected

  back over prevention: sensing system: camera

  Ford Motor Company (Ford) is recalling certain 2017-2020 F-Super Duty F-250, F-350, F-450, and 2017-2020 Lincoln Continental vehicles equipped with the 360-degree camera system. Degradation of the camera's anit-reflective lens coating can lead to a foggy or cloudy rearview camera image.

  Lack of a clear rearview camera image can reduce the driver's visibility of what is behind the vehicle, increasing the risk of a crash.

  Remedy

  Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed July 14, 2023. Owners may contact Ford customer service at 1-800-1-866-436-7332. Ford's number for this recall is 22S51.

• NHTSA recall #22V087000February 16, 2022247,445 vehicles affected

  power train: driveline: driveshaft; structure: frame and members: underbody shields

  Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.

  A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.

  Remedy

  Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.

• NHTSA recall #19V880000December 11, 2019490,574 vehicles affected

  seat belts: pretensioner; structure: body: roof and pillars

  Ford Motor Company (Ford) is recalling certain 2017-2019 F-Super Duty F-250, F-350, F-450, and F-550 SuperCrew Cab vehicles with carpet flooring. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.

  A vehicle fire could result if materials ignite inside the vehicle.

  Remedy

  Ford will notify owners, and dealers will apply heat resistant tape to the carpet and its insulation, and modify the B-Pillar insulation as necessary, free of charge. The recall is expected to begin January 20, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S52.

• NHTSA recall #19V864000December 4, 2019231,664 vehicles affected

  latches/locks/linkages: tailgate: latch

  Ford Motor Company (Ford) is recalling certain 2017-2019 Super Duty F-250, F-350, and F-450 trucks equipped with an electric tailgate latch release switch mounted in the tailgate handle. Water may enter the electrical wiring system and cause a short circuit, activating the switch and releasing the tailgate latches.

  Unintended tailgate opening may allow unrestrained cargo to fall out of the truck bed and become a road hazard, increasing the risk of a crash.

  Remedy

  Ford will notify owners, and dealers will modify the tailgate/frame wiring harnesses by adding jumper pigtails to isolate the tailgate release control circuits and will install a new tailgate handle release switch, free of charge. The recall is expected to begin January 20, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S48.

• NHTSA recall #19V278000April 8, 2019131,068 vehicles affected

  engine; equipment: electrical

  Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.

  A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.

  Remedy

  Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.

• NHTSA recall #17V652000October 16, 20171,101,107 vehicles affected

  latches/locks/linkages: doors: latch

  Ford Motor Company (Ford) is recalling certain 2015-2017 Ford F-150, and 2017 F-250, F-350, F-450, and F-550 Super Duty trucks. The doors on these vehicles may have a bent or kinked actuation cable or the door latches may freeze after water gets into the latch. Either condition can result in the doors opening while driving although they appear to be closed.

  A door that opens while driving can increase the risk of injury.

  Remedy

  Ford will notify owners, and dealers will inspect the door latch actuation cables and repair if necessary, and install water shields over the door latches, free of charge. The recall began October 12, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S33.

• NHTSA recall #17V599000September 25, 2017504 vehicles affected

  seat belts: front: anchorage; seats

  Ford Motor Company (Ford) is recalling certain 2017 Ford F-150, F-250, F-350, F-450, and F-550 trucks with manually-adjusted front passenger seats. The seat belt anchor may not be adequately welded to the seat cushion frame. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages," and 207, "Seating Systems."

  The seat belt buckle weld may fail, preventing the occupants from being properly restrained in the event of a crash, increasing the risk of injury.

  Remedy

  Ford will notify owners, and dealers will replace the front passenger manual seat track, free of charge. The recall is expected to begin November 6, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17C17.

• NHTSA recall #17V526000August 28, 2017117,423 vehicles affected

  seat belts: rear/other

  Ford Motor Company (Ford) is recalling certain 2015-2017 F-150, and 2017 F-250 and F-350 trucks equipped with a crew cab. The left rear inflatable seat belt buckle assembly may be inadequately attached to its mounting bracket. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages."

  If the left rear inflatable seat belt buckle separates from it's mounting bracket, the seat occupant may not be adequately restrained, increasing their risk of injury.

  Remedy

  Ford will notify owners, and dealers will inspect the seat belt assembly, replacing the attaching rivet as necessary, free of charge. Interim notices informing owners of the safety risk were mailed October 18, 2017. Owners will receive a second notice when the remedy becomes available. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 17C12.

• NHTSA recall #17V332000May 22, 20172,204 vehicles affected

  seats; seats: front assembly: recliner

  Ford Motor Company (Ford) is recalling certain 2017 Ford Explorer, F-150, F-250, F-350, F-450 and F-550 vehicles equipped with a manual driver's seat back recliner mechanism. In the event of a crash, the seat back frame may not restrain the occupant due to having inadequate welds. As such, these vehicles may not meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202a, "Head Restraints" and 207, "Seating Systems."

  If the occupant is not adequately restrained in the event of a crash, they have an increased risk of injury.

  Remedy

  Ford will notify owners, and dealers will inspect and, if necessary, replace the seat back frame, free of charge. The recall began on June 7, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for this recall is 17C08.

• NHTSA recall #17V225000March 31, 201748,443 vehicles affected

  power train: automatic transmission

  Ford Motor Company (Ford) is recalling certain 2017 Ford F-250 Super Duty trucks equipped with 6.2L engines and six-speed automatic transmissions. These transmissions may have a damaged park rod actuating plate that can result in unexpected vehicle movement even though the transmission has been shifted to 'Park.' As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 102, "Transmission Shift Lever Sequence/Starter Interlock/Transmission Braking Effect", and number 114, "Theft Protection."

  Unexpected vehicle movement such as a vehicle rollaway can increase the risk of a crash.

  Remedy

  Ford will notify owners, and dealers will inspect the park rod actuating plate and replace it, if necessary, free of charge. The recall began on June 1, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17C06.

• NHTSA recall #16V945000December 29, 20167,105 vehicles affected

  fuel system, gasoline: storage: tank assembly: mounting

  Ford Motor Company (Ford) is recalling certain 2017 Ford F-250 and F-350 Super Duty trucks manufactured August 10, 2016, to September 17, 2016. The frame reinforcement bracket may not have been attached to the front fuel tank strap, allowing the fuel tank strap to separate from the frame.

  A fuel tank strap that separates and allows the fuel tank to contact the ground may cause a fuel leak, increasing the risk of a fire.

  Remedy

  Ford will notify owners, and dealers will inspect and, if necessary, install the reinforcement bracket, free of charge. The recall began on February 7, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S45.

• NHTSA recall #16V778000October 26, 2016170 vehicles affected

  fuel system, diesel

  Ford Motor Company (Ford) is recalling certain model year 2017 Ford F-250 SD, F-350 SD, F-450 SD, and F-550 SD trucks manufactured March 21, 2016, to August 28, 2016. The protective shield on the fuel conditioning module may have inadequate adhesion, allowing the shield to become dislodged.

  If the shield becomes dislodged, the drain valve may open resulting in a fuel leak. A fuel leak, in the presence of an ignition source, increases the risk of a fire. Under certain conditions, significant liquid fuel on the road surface may cause a slip hazard, increasing the risk of a crash.

  Remedy

  Ford will notify owners, and dealers will replace the protective shield, free of charge. The recall began November 11, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S39.

Other model years

• 1997 39
• 1999 249
• 2000 233
• 2001 288
• 2002 245
• 2003 178
• 2004 254
• 2005 295
• 2006 274
• 2007 54
• 2008 141
• 2010 32
• 2011 122
• 2012 57
• 2014 26
• 2015 296
• 2016 291
• 2017
• 2018 399
• 2019 1,165
• 2020 267
• 2021 167
• 2022 127
• 2023 44
• 2024 40