1991 Eagle Premier

Complaint history

When NHTSA received these reports. Changes in reporting alone do not establish a change in failure rates.

Problems owners report

Listed groups have at least 3 complaints. The page includes the 20 largest groups plus any additional flagged groups; some complaints are not assigned to a group.

AI groups complaints by meaning; the groups are approximate. Share ratio compares the problem’s share of this vehicle’s complaints with its share on other vehicles over the last 24 months (shown from 3 recent complaints). A 2× ratio means twice the complaint share, not twice the failure risk. Flags mark unusual shares or recent surges after an AI review of the complaint content. “First signal” does not mean the pattern has persisted continuously.How recall estimates are calculated.

Recalls

• NHTSA recall #98V005000January 12, 1998293,369 vehicles affected

  service brakes, hydraulic: foundation components: disc: rotor

  Vehicle description: passenger and multi-purpose vehicles originally sold or currently registered in the states of connecticut, illinois, indiana, maine, maryland, massachusetts, michigan, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, or wisconsin, and the district of columbia. The front disc brake rotors Can experience severe corrosion if operated for an extensive period in the "salt belt." if the rotors are not replaced, the corrosion Can eventually compromise the structural integrity of the stamped steel center hub section of the rotor.

  The reduced strength Can allow the cast iron wear surface to separate from the hub, reducing the brake effectiveness of the vehicle.

  Remedy

  Dealers will replace these rotors with rotors that are coated with a corrosion protection.

• NHTSA recall #96V099000June 13, 1996321,000 vehicles affected

  service brakes, hydraulic: antilock/traction control/electronic limited slip

  The ABS hydraulic control unit Can experience excessive brake actuator piston seal wear causing pump-motor deterioration.

  If this condition occurs, the ABS function could be lost and reduced power assist would be experienced during vehicle braking increasing the potential for a vehicle accident.

  Remedy

  Dealers will test the vehicle's anti-lock brake system and repair the vehicles if necessary. Also the warranty on all ABS components will be extended to 10 years or 100,000 miles (except for the brake actuator piston assembly and the pump-motor assembly which will have a lifetime coverage). Owners will also be reimbursed for previous ABS component repair costs.

• NHTSA recall #95V213000November 7, 199590,000 vehicles affected

  seat belts: front: anchorage

  The automatic shoulder belt systems Can malfunction and become inoperative.

  The lack of passive restraints could increase the risk of personal injury in the event of a vehicle collision.

  Remedy

  Dealers will replace the system track and drive assembly on automatic shoulder belt systems which are currently inoperative and those systems when they become inoperative in the future.

• NHTSA recall #94V006000January 11, 1994125,000 vehicles affected

  visibility: defroster/defogger/hvac system: heater core

  The end cap connecting the heat exchanger's core to the engine cooling system could rupture and allow hot coolant to escape into the passenger compartment.

  The coolant escaping into the passenger compartment could contact the driver's feet and injure the driver. Also, steam from the heater liquid will cloud on the window surfaces and impair the driver's vision. In either case, failure of the heater core end cap could result in a vehicle accident.

  Remedy

  A coolant temperature controlled heater core fluid bypass valve will be installed.

• NHTSA recall #91V191000November 1, 199180,000 vehicles affected

  service brakes, hydraulic: foundation components: hoses, lines/piping, and fittings

  The anti-lock brake system high pressure hose may leak or detach at its crimped end fitting resulting in the discharge of hydraulic fluid.

  Fluid discharge eventually causes the loss of both theanti-lock brake system and hydraulic assist for the brake system, resulting inincreased likelihood of brake lockup and increased stopping distances, whichcould result in a vehicle accident.

  Remedy

  Replace the ABS high pressure hose with a hose of different design and construction.

• NHTSA recall #91V042000March 11, 19915,500 vehicles affected

  electrical system: 12v/24v/48v battery

  Routing of battery main feed wiring may allow it to contact the air cleaner bracket and contnued contact may lead to an electrical short circuit.

  The electrical short caused by continuous contact couldresult in the ignition of the wiring insulation, and an underhood fire.

  Remedy

  The main feed on all involved vehicles will be rerouted and secured with tie straps away from the air cleaner bracket.

• NHTSA recall #91V027000February 13, 199176,000 vehicles affected

  service brakes, hydraulic: foundation components: hoses, lines/piping, and fittings

  Rear brake tube routing is contacted by fuel tank heat shield when suspension is in full jounce position. This damages the brake fluid tube, causing a leak.

  Loss of fluid from half of the diagonally split brakehydraulic system affects braking capability, which could result in an accident.

  Remedy

  Modify heat shield to eliminate potential for shield contacting brake tube.

Other model years

• 1988 54
• 1989 67
• 1990 25
• 1991