2023 Chevrolet Tahoe

Complaint history

When NHTSA received these reports. Changes in reporting alone do not establish a change in failure rates.

Problems owners report

Listed groups have at least 3 complaints. The page includes the 20 largest groups plus any additional flagged groups; some complaints are not assigned to a group.

AI groups complaints by meaning; the groups are approximate. Share ratio compares the problem’s share of this vehicle’s complaints with its share on other vehicles over the last 24 months (shown from 3 recent complaints). A 2× ratio means twice the complaint share, not twice the failure risk. Flags mark unusual shares or recent surges after an AI review of the complaint content. “First signal” does not mean the pattern has persisted continuously.How recall estimates are calculated.

Recalls

• NHTSA recall #25V619000September 18, 202512 vehicles affected

  fuel system, diesel: storage: tank assembly

  General Motors, LLC (GM) is recalling certain 2021 Cadillac Escalade, 2021, 2023-2024 Chevrolet Tahoe, and 2022 and 2024 GMC Yukon vehicles equipped with a 6-cylinder diesel engine. The original fuel tank may have been replaced with an incorrect fuel tank, which can allow fuel to leak in a rollover crash.

  A fuel leak in the presence of an ignition source increases the risk of a vehicle fire.

  Remedy

  Dealers will inspect for the correct fuel tank and replace it, if necessary, free of charge. Owner notification letters were mailed November 5, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252512770. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 18, 2025.

• NHTSA recall #25V274000April 24, 2025597,571 vehicles affected

  engine and engine cooling: engine: hard parts internal/mechanical

  General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.

  Engine failure increases the risk of a crash.

  Remedy

  Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.

• NHTSA recall #24V674000September 12, 2024449,671 vehicles affected

  service brakes, hydraulic: brake fluid low warning: lamp; service brakes, hydraulic: power assist: electric: control module: software

  General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."

  Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.

  Remedy

  The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.

• NHTSA recall #23V642000September 20, 2023189 vehicles affected

  suspension: rear

  General Motors, LLC (GM) is recalling certain 2023 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Yukon, and Yukon XL vehicles. The rear suspension outer control arm bolts may not have been properly heat-treated, which can cause the bolts to break.

  A broken suspension bolt can result in misalignment of the rear wheel, increasing the risk of a crash.

  Remedy

  Dealers will replace both rear suspension outer control arm bolts, free of charge. Owner notification letters were mailed November 14, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N232415910.

• NHTSA recall #22V903000December 8, 2022740,108 vehicles affected

  exterior lighting: lighting control module: software

  General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

  DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.

  Remedy

  The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.

Other model years

• 1995 246
• 1996 283
• 1997 410
• 1998 263
• 1999 552
• 2000 282
• 2001 512
• 2002 449
• 2003 507
• 2004 467
• 2005 293
• 2006 114
• 2007 1,177
• 2008 528
• 2009 284
• 2010 314
• 2011 447
• 2012 178
• 2013 233
• 2014 90
• 2015 659
• 2016 256
• 2017 175
• 2018 105
• 2019 109
• 2020 57
• 2021 462
• 2022 197
• 2023
• 2024 69
• 2025 52
• 2026 28