2005 Chevrolet Avalanche

Complaint history

When NHTSA received these reports. Changes in reporting alone do not establish a change in failure rates.

Problems owners report

Listed groups have at least 3 complaints. The page includes the 20 largest groups plus any additional flagged groups; some complaints are not assigned to a group.

AI groups complaints by meaning; the groups are approximate. Share ratio compares the problem’s share of this vehicle’s complaints with its share on other vehicles over the last 24 months (shown from 3 recent complaints). A 2× ratio means twice the complaint share, not twice the failure risk. Flags mark unusual shares or recent surges after an AI review of the complaint content. “First signal” does not mean the pattern has persisted continuously.How recall estimates are calculated.

Recalls

• NHTSA recall #05V163000April 22, 20051,359,824 vehicles affected

  seat belts: rear/other

  On certain crew cab pickup trucks and sport utility vehicles, the 2ND row center occupant seat belt routing may make it difficult to position the lap portion of the safety belt low around the hips of occupants, especially smaller occupants, seated in this position. Appropriate use of a child seat or booster seat, as recommended for small children, does improve the fit condition for this user group. In addition to instructions on proper infant and young child restraint (with child seats or boosters), special verbiage for restraining older child is included in the owner's manual. Also, the suggested seat belt fit/routing for adults, irrespective of seating position, is described in the owner's manual text.

  A lap portion of the seat belt routing that is not low and snug on the hips Can allow the lap belt to ride up on an occupant's abdomen instead of fitting low around their hipbones, and therefore, Can expose them to more risk of abdominal and internal organ injury.

  Remedy

  Dealers will cut open the guide loop, remove a portion of the loop, and then the remaining two sides should be folded over and secured with a retainer free of charge. The recall began on july 21, 2005. Owners may contact Cadillac at 1-866-982-2339, Chevrolet at 1-800-630-2438, Gmc at 1-866-996-9463, or Hummer at 1-800-732-5493.

• NHTSA recall #05V055000February 14, 20057,194 vehicles affected

  power train: manual transmission: shift pattern indicator

  Certain sport utility vehicles equipped with an automatic transmission, fail to comply with the requirements of federal motor vehicle safety standard no. 102, "transmission shift lever sequence, starter interlock and transmission braking effect." under certain vehicle starting conditions, the shift lever position indicator located in the instrument panel cluster may not illuminate. If the shift lever position indicator does not illuminate, the driver may not know which gear the vehicle is in.

  The vehicle may move in an unintended direction resulting in possible injury to others outside of the vehicle.

  Remedy

  Dealers will reprogram the instrument panel cluster free of charge. The recall began on february 14, 2005. Owners may contact Cadillac at 1-866-982-2339, Chevrolet at 1-800-630-2438, and Gmc at 1-866-996-9463.

• NHTSA recall #05V043000February 8, 200577,411 vehicles affected

  service brakes, hydraulic

  Certain trucks, sport utility vehicles, and vans equipped with bosch hydro-boost brake assemblies, the hydraulic brake booster pressure accumulator may crack and separate from the hydro-boost assembly during normal operating conditions.

  If a separation occurred and the hood of the vehicle were open, fragments from the accumulator could cause injury to people in the immediate area. The presence of this crack or fractured surface could allow the hydraulic fluid to leak from the accumulator circuit of the booster assembly. The loss of fluid would cause increased steering and braking effort and a crash may occur without prior warning.

  Remedy

  Dealers will test the hydro-boost assembly for functional operation of the two-function valve. If the hydro-boost assembly fails the test, dealers will replace the assembly free of charge. The recall began on march 23, 2005. Owners may contact Chevrolet at 1-800-630-2438, Gmc trucks at 1-866-996-9463 and Hummer at 1-800-732-5493.

Other model years

• 2002 444
• 2003 204
• 2004 165
• 2005
• 2007 377
• 2008 258
• 2009 76
• 2010 111
• 2011 127
• 2012 36
• 2013 82